Professional Documents
Culture Documents
Manual
Manual
for Windows
MODEL.SKD12
Service Manual
0 0 1 0 0
10.10
No. SKD12
Warning
1 . Any part of this software and its service manual must not be duplicated or
plagiarized.
2. The use rule of this software is that a set of software is only used in a computer.
3. Corresponding alteration may be made for the specifications of this software and
the items recorded in the service manual with the upgrade of edition in the future.
Table of Contents
1 General ・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・・ 1
Appratus setting
Operatio
Display picture Description of operation
n key
MENU 1.NORMAL
2.SAMPLING TIME When the high voltage of apparatus is not
3.DATA OUTPUT applied, depress “MENU”key and enter the
4.PRINT OUTPUT menu picture as shown in following figure.
5.DATA CLEAR Depress △ ▽ key, choose various items.
6.TIME ADJUST Depress “SET”key and enter various submenus.
7.COMMUNICATION Depress“SET”key in item 7 “COMMUNICATION”,
quit the menu.
2.SAVE INFO
KD12 Backplate
2) If computer has no 9-pin COM port, USB-RS232 conversion port can be used for the
connection.
Front panel of
host computer
KD12 Backplate
Item Contents
Operating Microsoft Windows 2000 Professional
system Microsoft Windows XP Home Edition
Microsoft Windows XP Professional
Language English or simplified Chinese
Item Contents
Communication COM port COM1---COM8
setting Baud rate 9600
Bit 8
Data bit non
Stop bit 1(fixed)
Figure 2-1
③Following figure is the confirmation picture of installation path of the software. Please click the
installation icon if no alteration is made.
Icon
installation
Figure 2-2
④ Choose the Program Group for software installation. The installation program will default the
Program Group as the program group of “KANOMAX”. If no alteration is made, click Continue
button, and enter the installation picture of figure 2-4.
Figure 2-3
Figure 2-4
Figure 2-5
3.Use method of the software
3.1 Startup software
Click〖begin menu〗-〖program〗-〖KANOMAX〗–〖Piezobalance Dust Monitor Software〗
Start up piezobalance dust meter software.
<Startup picture>
Port Drive name File storage
File name
Program datasheet
File list
Description:
Item Scope
File name
Description:
1)Choose communication port: (COM1……COM8)
5) Click the button, read data, and display the data in the
datasheet on the left. The file name is displayed in following file lists
for next acquisition (in file list, click the file name to be read, and
display corresponding data in datasheet on the left).
6)Program state:display “reading data”.
7)Click the button, and close the software.
Attention:
1) Before reading data, please supply power to the instrument and put the
statue of power to "ON",if you press "reading key" when the power is not
supplied to the instrument,it may indicated error.