Professional Documents
Culture Documents
Bow Tie Instructions
Bow Tie Instructions
7. Turn right side out all pieces and press. Seams in A&B pieces should be in the center of one
side.
8. Piece B: Fold in 1/3 inch (1 cm) on each end of the tube and press.
Place Velcro on both ends of piece B and sew them on. Remember to sew Velcro on two opposite
sides of piece C (one on the side with the seam and the other one on the side without the seam).
9. Take your piece C and fold it to mark the half of this piece. Continue folding as shown in the
pictures.
10. Place folded piece C on the piece B and pinch the middle to form the shape of the bow.
Secure both pieces with a pin. Thread your needle through all layers and go back and forth a few
times securing the shape and then tie a knot in the end.
11. Piece A: Fold it in half and stitch 3/4 inch (2 cm) from the folded edge. Trim the excess fabric
and flip so the raw edge is on the inside.
12. Take pieces B and C and push them through the ring (piece A), until the ring is in the center
of the bowtie. Secure them with a few hand stitches.