Professional Documents
Culture Documents
ISO 3691-1-2011 Amd1-2020
ISO 3691-1-2011 Amd1-2020
STANDARD 3691-1
First edition
2011-09-15
AMENDMENT 1
2020-02
Reference number
ISO 3691-1:2011/Amd.1:2020(E)
© ISO 2020
ISO 3691-1:2011/Amd.1:2020(E)
Foreword
ISO (the International Organization for Standardization) is a worldwide federation of national standards
bodies (ISO member bodies). The work of preparing International Standards is normally carried out
through ISO technical committees. Each member body interested in a subject for which a technical
committee has been established has the right to be represented on that committee. International
organizations, governmental and non-governmental, in liaison with ISO, also take part in the work.
ISO collaborates closely with the International Electrotechnical Commission (IEC) on all matters of
electrotechnical standardization.
The procedures used to develop this document and those intended for its further maintenance are
described in the ISO/IEC Directives, Part 1. In particular, the different approval criteria needed for the
different types of ISO documents should be noted. This document was drafted in accordance with the
editorial rules of the ISO/IEC Directives, Part 2 (see www.iso.org/directives).
Attention is drawn to the possibility that some of the elements of this document may be the subject of
patent rights. ISO shall not be held responsible for identifying any or all such patent rights. Details of
any patent rights identified during the development of the document will be in the Introduction and/or
on the ISO list of patent declarations received (see www.iso.org/patents).
Any trade name used in this document is information given for the convenience of users and does not
constitute an endorsement.
For an explanation of the voluntary nature of standards, the meaning of ISO specific terms and
expressions related to conformity assessment, as well as information about ISO's adherence to
the World Trade Organization (WTO) principles in the Technical Barriers to Trade (TBT), see
www.iso.org/iso/foreword.html.
This document was prepared by Technical Committee ISO/TC 110, Industrial trucks, Subcommittee
SC 2, Safety of powered industrial trucks.
A list of all parts in the ISO 3691 series can be found on the ISO website.
Any feedback or questions on this document should be directed to the user’s national standards body. A
complete listing of these bodies can be found at www.iso.org/members.html.
4.2.3.3
Add new first paragraph before existing text as follows:
The speed of reach trucks shall be reduced automatically without causing a hazard to vmax ≤ 6 km/h
as determined by the manufacturer when the elevated section of the mast is more than 400 mm
above the height of the mast when fully lowered (see Figure 7).
Dimensions in millimetres
Key
h height of mast when fully lowered
6.2.2
Add new list item gg) as follows:
gg) information or instructions regarding modification of the truck, which can introduce hazards or
risks not considered by manufacturers and can invalidate the existing truck risk assessments.
6.2.7
Replace the entire subclause with the following:
Truck modification outside Europe is subject to regional requirements (see ISO/TS 3691-8).
ICS 53.060
Price based on 2 pages