Professional Documents
Culture Documents
Short To Batt
Short To Batt
· The ECM reads signal voltage that is above 5.5 VDC for two seconds.
· The ECM has been powered for at least three seconds.
System Response:
The ECM will log the diagnostic code. The diagnostic code may be viewed on
a display module or on ET. The ECM flags all analog sensors as invalid data
and all analog sensors are set to the respective default values.
· Low power
Troubleshooting:
Test Step 1. Perform the following diagnostic procedure: "5 Volt Engine
Pressure Sensor Supply Circuit - Test".
Results:
· OK- STOP.
Copyright 1991, 2005 Caterpillar Inc.
All Rights Reserved.