Professional Documents
Culture Documents
Diagram
Diagram
1
The study of drying process is to be done to verify the wet granules are dried to required level of
moisture. Collect the samples from 9 locations for determination of Loss on drying. 3 samples from
Top (T1, T2, T3), 3 sample from middle (M1, M2, M3) and 3 samples from Bottom (B1, B2, B3).
T1 T2
T3
M1 M2
M3
B1 B2 B3
Fig. No. 1
Abbreviations: T1: Top Left, T2: Top Middle, T3: Top Right B1: Bottom Left, B2: Bottom Middle, B3:
Bottom Right), M1: Middle Left, M2: Middle, M3: Middle Right.
Conta blender. Lubrication Process Validation: Fig. No. 2
To study the lubrication process and to ensure the uniform mixing is done in Conta blender.
Samples are to be drawn from 10 different sampling locations and one Composite Sample Test to
be performed as per in process specification.
A
F
C G
B
I D H
Fig. No. 2
Abbreviations: A: Front Top Left, B: Front Middle Left, C: Front Top Right, D: Front Middle Right,
E: Back Top Left, F: Back Middle left, G: Back Top Right, H: Back Middle Right, I: Center Middle
J: Bottom Center
9.3 SAMPLING LOCATIONS FOR OCTAGONAL BLENDER
After completion of mixing for the defined period of time, the samples shall be collected
from different locations as Shown in diagram.
BS1-Top right
BS2-Top middle
BS3-Top left
BS4-Middle right
BS5-Middle middle
BS6-Middle left
BS7-Bottom right
BS8-Bottom middle
BS9-Bottom left
BS10-Near Discharge Port
BS-2
BS-1` BS-3
BS-10
SAMPLING LOCATIONS FOR RAPID MIXER GRANULATOR
After completion of mixing for the defined period of time, the samples shall be collected
from different locations as Shown in diagram.
DS1-Top Middle
DS2-Middle right
DS3-Middle middle
DS4-Middle left
DS5-Bottom middle
Top position
S1
Middle position
S2 S4
S3
S5
Bottom position
T1
B1 C
T2
B2
Fig. No. 3
Abbreviations: T1: Top Left, T2: Top Right, B1: Bottom Left, B2: Bottom Right, C: Center