Professional Documents
Culture Documents
Buckling Analysis Example
Buckling Analysis Example
Security Classification:
EG001-11RV1AMEA0-F99-0012 Submittal: 01
Document Status: 5
Signed By: Holt_Barry
Permission to proceed does not constitute acceptance or approval of design details, calculations,
analysis, test methods, or materials developed or selected by the Third Party and does not relieve the
Third Party from full compliance with contractual obligations.
ELECTRONIC DOCUMENTS ARE CONTROLLED. ANY PRINTED COPY WILL BE UNCONTROLLED AND MAY BECOME OUTDATED
BP West Nile Delta
Gas Development Project
Security Classification:
ELECTRONIC DOCUMENTS ARE CONTROLLED. ANY PRINTED COPY WILL BE UNCONTROLLED AND MAY BECOME OUTDATED
Tube Buckling Analysis For Flash Gas Compressor After cooler Item No. Gas Compressor After Cooler A-2721 A/B
TABLE OF CONTENT
1.0. Introduction
1. Introduction
This report summarizes the Tube buckling check under operating condition.
The dimensional general information for A-2721 specified to this analysis are
Typically the stress analysis is determined using an equivalent static analysis procedure.
This analysis is accomplished using the ANSYS program that is based on the
Finite Element Method (FEM) and recognized internationally for following proposes;
. Dynamic Analysis
. Optimization Analysis
2. Design Criteria
[Table 1]
DESIGN DATA
Case3A
3. FEA Analysis
For the finite element model of Plates and Tube, 3D Solid 185 elements is modeled
Tube 1 5.3918 OK