Professional Documents
Culture Documents
6TH Old 23
6TH Old 23
GROUP – A (5)
(a) Ozone
(b) Photo chemical smog
(c) SO2
(d) All of these
ii. Which of the following is not considered as pollutant? 1
(a) CO
(b) CO2
(c) SO2
(d) NO2
iii. Presence of _____ is responsible for the temporary hardness in water. 1
(a) Bicarbonates
(b) Sulphates
(c) Chlorides
(d) Calcium
iv. Biological treatment method of water in the absence of oxygen is called. 1
(a) Aerobic
(b) Anaerobic
(c) Neutralization
(d) Aeration
v. Odour of the water is measured by the _____. 1
(a) Tintometer
(b) Osmoscope
(c) Thermometer
(d) B-Coli Test
GROUP – B (answer any two) (5)
2. 2.5
Write down the physical characteristics of waste water and explain any one.
3. Give application and working of Electrostatic precipitator? 2.5
ii) Which of the following is used as a catalyst in fluidized bed catalytic cracking ?
(A) Silica-magnesia (B) Silica-alumina
(C) Betonies clays (D) All (a), (b) and (c)
Group-B
Answer any two out of the three questions given below. 2.5x2=5
1. Define:
(i) Octane number (ii) Cetane number
2. Write the definition and significance of following: Flash and Fire Point.
3. What is cracking? Discuss the properties of cracked materials
Group-C
Answer any two out of the three questions given below. 5X2=10
(A) Binary (B) ternary (C) constant boiling point (D) none of these
v). If G = insoluble gas in gas stream and L = non-volatile solvent in liquid stream, then the slope
of the operating line for the absorber is
(A) L/G (B) G/L (C) always < 1 (D) none of these
Group-B
Answer any two out of the three questions given below. 2.5x2=5
Group-C
Answer any two out of the three questions given below. 5X2=10
4. Derive the expression of operating line of rectifying section in a distillation
column.
5. Derive the expression of operating line of stripping section in a distillation
column.
6. A distillation column separates 10,000kg/h of a benzene-toluene mixture as
shown in the figure below. In the figure xF,xD, and xw represent the weight
fraction of benzene in the feed, distillate, and residue, respectively. Find the
Reflux Ratio.
G. P. Barauni, Begusarai
Class Test 2023(EVEN)
Branch: Chemical engg. (6 th sem)
Time: 1:30 hrs Subject: Chemical engineering Drawing Full Marks:20
Group-A 5x1=5
i). Which of the following facilitates close control of flow of fluids.
(A) Gate valve (B) Globe valve (C) Butterfly valve (D) check valve
(C) True temperature difference - L.M.T.D. (D) L.M.T.D. - True temperature difference
Group-B
Answer any two out of the three questions given below.
2.5x2=5
Group-C
Answer any two out of the three questions given below. 5X2=10
4. Prepare a neat specification sheet of the Shell and tube heat exchanger.
5. Draw a neat and proportionate sketch of Jacketed batch reactor.
6. Draw a neat labelled fabrication diagram for a 2-4 pass shell and tube heat
exchanger?