Professional Documents
Culture Documents
0 515 012 068 - Voltmeter
0 515 012 068 - Voltmeter
2QddUbi 7b_e^T
Diagram C
Proper wiring of the VDO Voltmeter Tools and Materials Needed For Installation:
16 Gauge stranded, insulated wire
Non-insulated ¼" spade connectors
2 ¹⁄₁₆" hole saw or 2 ⁵⁄₈" hole saw
Voltmeter
Drill and drill bit set Installation Instructions
Half-round file Instruction Sheet #0 515 012 068
Rev . 08/09
Tape measure or ruler INSTRUCTIONS FOR THE INSTALLATION OF THE VOLTMETER ARE CONTAINED
Small tools: wrench or nut driver, utility HEREIN. USE IS RESTRICTED TO 12 or 24-VOLT NEGATIVE GROUND
ELECTRICAL SYSTEMS.
'LPHQVLRQ ¬%
'LPHQVLRQ ¬$ plete. Turn on the ignition and the lights
in the car and check to see that the
2. Connect the positive (+) and nega- imstrument and light are working prop-
tive [ground] () wires as shown in Dia- erly. If they arent, re-check your wiring,
gram C. referring to the wiring description in Dia-
3. Connect the appropriate positive (+) gram C.
PP
PD[ PP
!'&
$$']] !'
((""#]]
$#]] Mounting Nut direction
depends on panel width
A: 0 .4" (0 10 mm)
B: .4" .8" (10 20 mm)
DO NOT OVERTIGHTEN! é
4Y]U^cY_^²1³
4Y]U^cY_^²2³
"=$
ð
TOP:
VDOs Spin-Lokä
Mounting Clamp
LEFT:
ç VDO Mounting Bracket
Diagram A Diagram B
Gauge dimensions Mounting using VDO Mounting Bracket or VDO Spin-Lokä Clamp