Professional Documents
Culture Documents
TL1114 en
TL1114 en
51 25 5 February 2004
Norm vor Anwendung auf Aktualität prüfen / Check standard for current issue prior to usage.
Micro-Alloyed Hot Rolled Strip-36 TL
Fine Grain Grade 1114
In case of discrepancies the German version shall govern.
Material Requirements
Konzernnorm
The English translation is believed to be accurate.
Descriptors: hot-rolled strip steel, hot rolled strip, micro-alloyed, fine grain grade, strip steel,
strip, engine carrier
Changes
The following changes have been made as compared to Technical Supply Specification
TL 1114, 1998-04:
ņ Referenced standards updated
Previous issues
1998-04
1 Scope
This Technical Supply Specification (TL standard) specifies the material requirements for micro-
alloyed hot rolled strip-36, fine grain grade, for superior forming properties during pressing,
e.g., engine carriers.
2 Description
Micro-alloyed hot rolled strip according to TL 1114
3 Requirements
Page
Fachverantwortung/Responsibility Normung/Standards (EZTD, 1733)
K-QS-32 Klingemann Tel:-28499 Frau Hager-Süß Tel: +49-5361-9-49035 Sobanski
Confidential. All rights reserved. No part of this document may be transmitted or reproduced without the prior written permission of a Standards Department of the Volkswagen Group.
Parties to a contract can only obtain this standard via the responsible procurement department.
© VOLKSWAGEN AG
Page 2
TL 1114: 2004-02
3.5.1 General
As ordered.
3.7.1 Surface
Surface free of coarse pores, splinters and rolling marks (according to DIN EN 10130, surface
finish A).
3.7.3 Density
7.85 kg/dm3
Page 3
TL 1114: 2004-02
Table 2
No. Property Unit Requirement
1 Tensile strength
General N/mm2 500 to 600
For rear axle carrier N/mm2 520 to 620
2 Yield point N/mm2 ≥ 360
3 Elongation at break % ≥ 22 (L0 = 80 mm)
4 Bend test α = 180°
acc. to DIN EN ISO 7438 D = 0 · a (a = specimen thickness)
During bending, no crack shall form on
the side of the specimens subject to
tension.
4 Referenced standards*)
VW 011 55 Vehicle Supply Parts; Approval of First Supply and Changes
VW 911 01 Environmental Standard for Vehicles, Vehicle Parts, Materials, Operating
Fluids; Avoidance of Hazardous Substances
DIN EN 10130 Cold Rolled Low Carbon Steel Flat Products for Cold Forming – Technical
Delivery Conditions
DIN EN ISO 643 Steels – Micrographic Determination of the Apparent Grain Size
DIN EN ISO 7438 Metallic Materials – Bend Test
*)
In this section, terminological inconsistencies may occur as the original titles are used.