Professional Documents
Culture Documents
Unpaved Strip Kit
Unpaved Strip Kit
Home > History and Variants > 737 Originals > Unpaved Strip Kit
Contents
The optional Upaved Strip Kit was made available for the 737-100/200 from Feb 1969. It allowed aircraft to operate from gravel, dirt or grass strips. At its peak of
operation, 737s were making over 2000 movements a year from unpaved runways.
Whatever surface was to be used, certain guidelines had to be observed. The surface had to be smooth with no bumps higher
than 3 inches in 100ft; good drainage with no standing water or ruts; and the surface material had to be at least 6 inches thick
with no areas of deep loose gravel. Boeing offered a survey service to assess the suitability of potential strips. If a surface was
not particularly hard it could still be used by reducing tyre pressure down to a minimum 40psi in accordance with a chart.
Components included:
The protective equipment listed above means that extra maintenance costs due to tire wear, paint loss, etc is only about $15 per
landing (1975 rates).
Vortex Dissipators
Prevent vortices forming at the engine intakes which could cause gravel to be ingested by
engine. These consist of a small forward projecting tube which blows pressure regulated (55psi)
engine bleed air down and aft from 3 nozzles at the tip to break up the vortices.
The dissipators are operated by a solenoid held switch on the overhead panel which switches
off on a squat switch so that climb performance is not affected. (Similar to the wing anti ice
switch on 3-900 series).
The GRAVEL PROTECT switch must be on or at the ANTI-ICE/TEST position at any time the
engines are running on the ground. Take-offs and landings must be made with the engine
bleeds off to ensure that there is sufficient bleed air for their effective operation. Air conditioning
may be used with APU bleed air if required.
The GRAVEL PROTECT switch for the anti-vortex jets under the engine n
The blue caption says RETRACT for the retractable anti-collision light.
This photo shows the airflow patterns in the gravel from the 3 nozzles of the vortex generator.
The nose gear gravel deflector is made of corrosion-resistant steel and has a sheet metal
leading edge which acts as an aerofoil to give it aerodynamic stability.
When the gear retracts, the deflector is hydraulically rotated around the underneath of the nose
wheel before seating into the faring at the front of the nose wheel well. The rotation is
programmed to maintain the deflector in a nose-up attitude during transit. No extra crew action
is required to use the deflector and in the event of a manual gear extension, springs and rollers
will position it correctly.
The maximum speed for gear operation (V LO) is reduced considerably to 180kts and the max
speed with the gear extended (V LE) is only 200kts.
Note that the ground clearance of this nose-gear unit is only 3.5 inches this is enough to allow
for flat tyre clearance but care must be taken when crossing runway arrestor cables, particularly
try to avoid taxying over the "doughnuts" that support any cables.
Click here for photo of 737-200 fitted with full unpaved strip kit.
Operational Procedures
This tyre screen is to protect vital components from damage if debris is flung into the wheel well from an unpaved strip.
This is a video of the unpaved landing trials narrated by Peter Morton, 737 Marketing; and Lew Wallick, one of the test pilots on the first flight of the 737.
https://www.youtube.com/watch?v=aOpBXmqa0eY