Professional Documents
Culture Documents
HW 101 C
HW 101 C
Q.1) Given the mass of the cylinder 4 gm. The length of a cylinder was measured by the vernier caliper, The
diameter of it was measured by the micrometer. Read the vernier caliper and the micrometer shown in figure
below and then calculate the density of the cylindrical rod in gm/cm3.
Q.2) In the force table experiment, pulley (1) was placed at 30o and added a weight of 2.2 N. Pulley (2) was
placed at 140o and added a weight of 1. 3 N. The resultant weight was 1.9 N.
a. If the equilibrium force is found at angle of 245o, then the resultant force will be at angle of
φ = ---------------------------------------
1
Experiment three: Acceleration on an inclined plane (5 Points)
Q.3) Find the mass of the glider from the following data? (𝑀𝐻𝑜 = 9 𝑔)
Good Luck