Professional Documents
Culture Documents
Compre A 19
Compre A 19
Compre A 19
Instructions: - There are fifteen questions. Read the questions carefully and write the (A) 𝐼 = ( )
(B) 𝐼 =𝐼 𝐷
answers in ONLY capital letters and ONLY in the space provided. Answers marked
anywhere else will NOT be evaluated. Every correct answer carries 3 marks Answer
All Questions. Overwriting or ambiguity will NOT be considered for evaluation. (C) 𝐼 = (D) 𝐼 =( )
Answers
1 2 3 4 5 6 7 8 9 10 6. The reverse recovery time of all diodes connected in a full bridge rectifier for
an R load is 50μsec. For an AC input voltage of 400V, 5kHz the average
output voltage is
11 12 13 14 15 No of Right Total Marks
(A) 565.69V (B) 127.32V (C) 254.64V (D) 282.84V
(A) less than 1 but real (B) less than 1 but complex
(C) greater than 1 but finite (D) infinite
12. A single phase uncontrolled bridge rectifier is supplied from 120V, 60Hz
source. The load resistance is 500Ω. If the ripple factor of output voltage in
percentage is limited to 5%, the designed value of capacitor is ______
14. A thyristor based AC-DC full bridge converter is supplied from a 230V, 50 Hz
single phase supply. An RL load, of R = 4.0Ω and L = 12.73mH is connected to
the converter. If the output current is to be continuous always, then the control
Fig. 2
range of triggering angle ________________________
(A) should be less than 450 (B) must be between 450 and 900
(C) should be greater than 900 (D) cannot be determined
15. For the circuit shown in Fig. 4, R = 44Ω, C = 0.1μF and initial voltage of
capacitor, Vco i.e.Vc (at t = 0) = 220V. If the switch is closed at t = 0, assuming
ideal condition for the diode, the maximum current flowing through the diode and
the capacitor voltage at t = 2μs is given as __________ A and
_______________V
Fig. 3 Fig. 4
(A) 5 A and 140V (B) 3.2 A and 140 V (C) 5 A and 80V (D) 1.8 A and 80V