Professional Documents
Culture Documents
Driver Information System: Section
Driver Information System: Section
K ELECTRICAL
B
SECTION
DRIVER INFORMATION SYSTEM C
E
CONTENTS
COMBINATION METERS ........................................... 2 Self-Diagnosis Procedure ......................................... 3 F
Circuit Diagram ........................................................ 2 Diagnosis Procedure ................................................ 4
Meter Control Unit Assembly Input/Output Signal DIAGNOSIS RESULTS ......................................... 4
Specifications ........................................................... 2 WARNING CHIME ....................................................... 6 G
Self-Diagnostic Function .......................................... 3 Circuit Diagram ......................................................... 6
Meter Control Unit Assembly Input/Output Signal
Specifications ........................................................... 6
H
DI
DI-1
COMBINATION METERS
SKIA1584E
Measurement condition
Terminal
Signal name Ignition Standard
No. Operation or condition
switch
40 Fuel gauge signal - - -
Disconnect ECM connector. Approx. 8V - 10V
PBIA0161J
DI-2
COMBINATION METERS
Measurement condition
Terminal A
Signal name Ignition Standard
No. Operation or condition
switch
B
Speedometer operated
Vehicle speed signal
62 ON (When vehicle speed is
(8-pulse)
approx. 40 km/h) C
ELF1084D
Speedometer operated
Vehicle speed signal
63 ON (When vehicle speed is E
(2-pulse)
approx. 40 km/h)
ELF1080D
F
Disconnect ECM connector. Approx. 8V - 10V
G
Engine coolant tem-
66 ON At idle (After warming up
perature signal
the engine)
H
SKIA0056J
1. Turn the ignition switch ON, and switch the odometer/trip meter to trip “A” or trip “B”. DI
NOTE:
If the diagnosis function is activated with trip meter “A” displayed, the mileage on trip meter “A” is reset to
0.0 km (same as trip meter “B” display). L
2. Turn the ignition switch OFF.
3. While pressing the odometer/trip meter switch, turn the ignition switch ON again.
4. Check that the trip meter displays “0000.0”. M
5. Press the odometer/trip meter switch at least 3 times in 5 seconds.
6. All odometer/trip meter segments illuminate. At same time, fuel
warning lamp illuminates. At this time, meter control unit assem-
bly has switched to diagnosis mode.
NOTE:
If any segments are not displayed, replace odometer/trip meter
together with meter control unit assembly.
EL-2563D
DI-3
COMBINATION METERS
7. Press the odometer/trip meter switch. In the normal status, the meters and gauges display as shown in
the figure while the odometer/trip meter switch is pressed and held (at this time, the low-fuel warning lamp
goes off).
SKIA0033J
SKIA0857E
DIAGNOSIS RESULTS
Symptom Check item Malfunctioning item
● Fuel system.
Fuel warning lamp indication is irreg- ● Tachometer system.
NG
ular. Inspect the sensor system of the gauge ● Coolant temperature sys-
(warning lamp) with the irregular indica- tem.
tion.
There is display malfunction for one
of the following: tachometer, fuel OK ● Meter control unit assembly
gauge, coolant temperature gauge.
DI-4
COMBINATION METERS
DI
DI-5
WARNING CHIME
SKIA1585E
ON (open) Approx. 0
11 Driver door switch signal OFF Driver door
OFF (closed) Approx. 12
Vehicle key is removed. Approx. 0
43 Key detection switch signal OFF
Vehicle key is inserted. Approx. 12
59 Ground ON — Approx. 0
62 Battery power supply OFF — Approx. 12
DI-6