Professional Documents
Culture Documents
Palintest DPD No.3 Rapid Tablets
Palintest DPD No.3 Rapid Tablets
Product number PT224OX, WAG-WE10953-10, PTW600, AD-0302, AL030/100B, AT030, PK011, WAG-
WE10953-25, AT-8732, 66149195, ATW030, PTW10005UNIB, P224OX, SP319/M, SP611,
SP614
1.2. Relevant identified uses of the substance or mixture and uses advised against
Identified uses Testing water
National emergency telephone NHS Direct: 0845 4647 (England and Wales) NHS 24: 08454 24 24 24 (Scotland)
number
Hazard pictograms
1/6
Revision date: 21/12/2020 Revision: 14 Supersedes date: 03/02/2020
Supplementary precautionary P321 Specific treatment (see medical advice on this label).
statements P362+P364 Take off contaminated clothing and wash it before reuse.
3.2. Mixtures
Classification
Acute Tox. 4 - H302
Acute Tox. 4 - H312
Skin Irrit. 2 - H315
Eye Irrit. 2 - H319
The Full Text for all R-Phrases and Hazard Statements are Displayed in Section 16.
Inhalation Unlikely route of exposure as the product does not contain volatile substances.
Skin contact Wash skin thoroughly with soap and water. Get medical attention promptly if symptoms occur
after washing.
Eye contact Rinse immediately with plenty of water. Remove any contact lenses and open eyelids wide
apart. Continue to rinse for at least 15 minutes. Get medical attention if irritation persists after
washing. Show this Safety Data Sheet to the medical personnel.
4.2. Most important symptoms and effects, both acute and delayed
General information The severity of the symptoms described will vary dependent on the concentration and the
length of exposure.
4.3. Indication of any immediate medical attention and special treatment needed
2/6
Revision date: 21/12/2020 Revision: 14 Supersedes date: 03/02/2020
Protective equipment
3/6
Revision date: 21/12/2020 Revision: 14 Supersedes date: 03/02/2020
Eye/face protection Eyewear complying with an approved standard should be worn if a risk assessment indicates
eye contact is possible. The following protection should be worn: Chemical splash goggles.
Hand protection No specific hand protection recommended. Chemical-resistant, impervious gloves complying
with an approved standard should be worn if a risk assessment indicates skin contact is
possible. It is recommended that gloves are made of the following material: Nitrile rubber.
Other skin and body Wear appropriate clothing to prevent any possibility of skin contact.
protection
Hygiene measures No specific hygiene procedures recommended but good personal hygiene practices should
always be observed when working with chemical products. Wash promptly if skin becomes
contaminated.
Colour White.
Odour Odourless.
10.1. Reactivity
Reactivity There are no known reactivity hazards associated with this product.
4/6
Revision date: 21/12/2020 Revision: 14 Supersedes date: 03/02/2020
Eye contact Particles in the eyes may cause irritation and smarting.
Acute and chronic health Because of the product's quantity and composition, the health hazard is regarded as low.
hazards
Ecotoxicity There are no data on the ecotoxicity of this product. The product components are not
classified as environmentally hazardous. However, large or frequent spills may have
hazardous effects on the environment.
12.1. Toxicity
Toxicity No data available.
General The product is not covered by international regulations on the transport of dangerous goods
(IMDG, IATA, ADR/RID).
14.1. UN number
Not applicable.
5/6
Revision date: 21/12/2020 Revision: 14 Supersedes date: 03/02/2020
14.7. Transport in bulk according to Annex II of MARPOL and the IBC Code
Transport in bulk according to Not applicable.
Annex II of MARPOL 73/78
and the IBC Code
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
EU legislation Regulation (EC) No 1272/2008 of the European Parliament and of the Council of 16
December 2008 on classification, labelling and packaging of substances and mixtures (as
amended).
Revision comments NOTE: Lines within the margin indicate significant changes from the previous revision.
Issued by L. Morgan
Revision 14
This information relates only to the specific material designated and may not be valid for such material used in combination
with any other materials or in any process. Such information is, to the best of the company's knowledge and belief, accurate
and reliable as of the date indicated. However, no warranty, guarantee or representation is made to its accuracy, reliability or
completeness. It is the user's responsibility to satisfy himself as to the suitability of such information for his own particular use.
6/6