Professional Documents
Culture Documents
Job Safety AnalysisOverhauling Dismantling and Fitting of BA OTP AWP SWP VDP FASP BASP
Job Safety AnalysisOverhauling Dismantling and Fitting of BA OTP AWP SWP VDP FASP BASP
Department Name: Ash Handling Management System (AHMS) Permit to Work (PTW) Required: Yes No
Required PPE’s for execute job: Safety Helmet, Steel Toe Shoe, Safety Googles, Hand Gloves, Ear Plug.
3. Overhauling/Lifting 1. Hand injuries Caused by 1. An appropriate and valid PTW to be ensured. Appropriate PPEs should be worn by
Operation (Machine) of not using appropriate tools. the workers. Be cautious of hand injuries while using sharp tools and wear protecting
Centrifugal Pump 2. Equipment/ tool damage gloves. Unauthorized personal entry should be restricted.
Disassembly/Assembly due to inappropriate/
2. Load should not exceed SWL of machine/ rigging gears. Only 3rd party tested tools
substitute tools.
tackle should be used. There should only one signal man at the time, and he should be
visible to the operator (Hydra or EOT). No worker should be allowed near/ beneath
when load is in suspended condition.
4. Check the intended route 1. Slips, Trips & Falls 1. Inspect the area immediately around the load and the route for clearance and
and point of placement Crush Injury tripping hazards. Clear movable objects from the route. If the load must be carried for
a long distance, find location(s) load can be placed to allow for a rest break. If possible,
keep load elevated to avoid lifting the object to resume moving it
5. Install new pump, remove 1. Musculoskeletal injuries 1. Use proper lifting techniques and body mechanics.
equipment, reconnect wires, 2. Electrical hazard
2. Restore energize equipment If area is wet, check for frail, corroded, and/or exposed
refill water, re-energize, and
wires. Ensure proper isolation and cross check it. (Group LOTO removing is required
test the pump.
when working with others)
6. Housekeeping 1.Physical Injuries could 1. Ensure that after work, site is
occur while stepping on clean and tidy, remove all damage gasket, spare from location.
objects and tripping, slippery Clean surface from oil and grease that are used.
areas, and fall.
Required Training (Tick Which are applicable) 1. Hazard Communication (GHS) 2. Lock Out/Tag Out