Professional Documents
Culture Documents
GDP-3D Specification
GDP-3D Specification
GDP-3D Specification
The GDP-3D kit consists of two main parts, the survey tool itself and a portable
Android controller that is used to operate and present the borehole survey data. There
is a lithium battery inside the probe for the survey tool to get power. To connect to the
portable controller, turn on the survey tool and the controller itself, run the App and
then the program should automatically detect the GDP-3D probe and you are ready to
start your survey.
Sensor Part
Power Part
2.2 Specifications
The GDP-3D is a magnetic multi-shot survey tool. The electronic unit consists of three
magnetometers and three accelerometers. They measure the magnetic field and
gravity where the tool is placed along. The sensor data obtained during a survey is
stored in the internal memory of the tool and can be downloaded vie Bluetooth when
the tool is connected to the Android controller. The Power Part contains a 7.4v
rechargeable lithium battery, which can be charged no less than 500 times. The
adapter with an ID number “430xxx” is used to connect a steel wire and slowly lower it
down the hole. User can choose the spear-head or the screwed connector due to
different rig. The endurance of the probe is about 20 hours.
n roi ontroller
The controller to operate the survey tool runs Android 4.4.2. It is IP68 rated and is
impervious to water and dust. It has a rugged casing and integrated with GPS. The
controller has “Liqing” app installed when it is shipped. User can use the controller to
measure and check data. The app will be explained in more detail in section 3.3
2
More photo
Package List
3 Spear-head piece 1
9 U-disk piece 1
12 Certification piece 1