Professional Documents
Culture Documents
02-20 RDRTU-2
02-20 RDRTU-2
02-20 RDRTU-2
The RTU allows the use of an unlicensed radio modem 2 RDRTU, which can be used up to a
transmission power level of 500 mW to communicate with other remote devices in Master or Slave
MODBUS.
Refer to memo "Theoretical range calculation" to determine
the feasibility and reliability of communications.
General characteristics:
• 869.475 MHz
• 869.575 MHz
• 16 dBm / 40 mW
• 21 dBm / 125 mW
4 user configurable levels of transmission
power • 24 dBm / 250 mW
(∗): transmission power "27 dBm/500 mW" is reserved for an antenna without gain.
3 types of antenna are available according to the reception level and the topology of the terrain:
On certain types of antenna, the gain is specified in dBd (dBd = dBi - 2).
• In certain countries, there may be restrictions on the use of this frequency band;
for more information, please contact us.
Terminal strip of
Earth connection of the mast
the RD-RTU-2
1 meter and the coaxial cable shield.
RD-RTU-2 Box
Earth wire
N Plug
of the câble
50 meters
Poste
RD-RTU-2 module
Mounting bracket: this is used to offset the module to a high point, near the antenna, for
better reception level. It can either be screwed to the antenna mast or fixed to a vertical
surface.
"RD-RTU-2 - RS485A board" link: use a "2 pair" cable, one pair of which is shielded (T+,T-),
1.5 mm² in cross-section, with a reinforced, flexible and watertight sheath.
Maximum length of the cable the offset module: 50 meters.