Professional Documents
Culture Documents
Summer 2021 Question
Summer 2021 Question
Alimullah Miyan
1. Briefly discuss the applications of modulus of elasticity of materials with an example. [05]
2. In designing concrete structures, normally maximum aggregate sizes are adopted with [05]
ranges from 10mm to 20mm. Does an increase of maximum aggregate size benefit the
structures?
3. Make a flow chart of working procedure of Standard Penetration Test (SPT). [05]
4. A plot was measured by an Engineer's chain exactly 100 ft. in length at the beginning. [05]
But it was found to be 100.25 ft. long at the end of the survey work. The area of the plot
drawn to a scale of 1 inch = 100 ft. was 25.50 sq. inches. Find the true area of the plot.
5. Demonstrate a typical stress strain graph for mild steel and describe all the components [05]
of it.
6. Differentiate between normally consolidated and over consolidated soil. [05]
7. Discuss the types of pavement and Give description on the layers and coats inside a [05]
conventional flexible pavement
8. Explain one-way and two way eccentrically loaded foundation with a schematic diagram. [05]
9. Describe the slump test of concrete and explain how the w/c ratio affects the workability [05]
of concrete.
10. For residential building project, draw a work breakdown structure (WBS), and briefly [05]
discuss how WBS is going to help the Project Manager.
11. State the differences between fast tracking and crashing of a project. [05]
12. Mention the measures may be taken for the sustainable management of air pollution in [05]
Dhaka city,
13. Explain corner reinforcements in two-way slabs and the ACI provisions for corner [05]
reinforcements.
14. Describe Influence Line (IL) and explain the difference between Influence lines for [05]
determinate and indeterminate structures.
Page 1 of 2
Founded 1991 by Md. Alimullah Miyan
15. Discuss Moment-Distribution Method and method of consistent deformations and which [05]
method you would chose for BMD of indeterminate structures and why?
16. Sketch an indeterminate but unstable beam and explain [05]
17. Sketch a horizontal curve of a highway where the entry grade is (p − 9)% and exit grade [05]
(p − 7)% . Show different design points on the curve.
[Here, p = last 2 digits of your ID]
18. Consider a statically determinate beam, which is having a point load and a uniformly [05]
distributed load. You can assume the value and location of loads. However, you must
consider the length of the beam is (10+X) ft, where X= last two digits of your student ID.
For the prescribed beam, sketch the shear force and bending moment diagram.
19. Discuss physical, chemical, and biological treatment process of wastewater. [05]
20. Determine the forces CD, CG and HG of the following truss. [05]
Page 2 of 2