Professional Documents
Culture Documents
Maav 011018 Ma Com
Maav 011018 Ma Com
Maav 011018 Ma Com
5 - 3000 MHz, 75 Ω
MAAV-011018
Rev. V2
Applications
• DOCSIS 4.0 & Extended Spectrum DOCSIS
• CATV/DOCSIS Amplifiers and Nodes
• High Linearity Power Control
• Cable Modems
• Remote PHY
Ordering Information1,2
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
Pin Description
Name
1, 5, 6, 7,
GND These pins are not connected internally but should be grounded on the board in the shortest way.
8, 12, 13
2, 4, 9, 11 N/C These pins are not connected internally and can stay opened (or grounded) on the board.
This pin is DC coupled to ground internally. No external coupling capacitor is needed if the DC voltage
3 RFIN
applied is 0 V.
This pin is DC coupled to ground internally. No external coupling capacitor is needed if the DC voltage
10 RFOUT
applied is 0 V.
Control voltage. Standard diode ESD protection at the input. An external RC low pass filter is
14 VC
recommended to reduce noise.
15 VDD Supply voltage. Bypass with 1 nF close to the pin.
Slope control voltage. Digital input. 1.8 V to 3.3 V logic. Standard diode ESD protection at the input. An
16 VMODE
external RC low pass filter is recommended to reduce noise. V MODE = VC = 0 V is lowest attenuation.
Exposed paddle. This is where our reference case temperature is measured. Ground with as many vias
17 EP
as practical for electrical and thermal performance.
2
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
RF Electrical Specifications5:
Freq. = 1.8 GHz, TC = 25°C, Z0 = 75 Ω, VDD = 5 V, VMODE = 0 V, PIN = 0 dBm
5 MHz, VC = 0 V 0.4 —
1.2 GHz, VC = 0 V 0.7 —
Reference Insertion Loss dB —
1.8 GHz, VC = 0 V 1.0 1.5
3.0 GHz, VC = 0 V 1.8 2.3
3
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
Handling Procedures
Power Supply Sequencing
Please observe the following precautions to avoid
Pins VC and VMODE should be at zero before and damage:
when VDD is ramped up.
Static Sensitivity
VDD should not ramp faster than 1 V / 20 µs. These electronic devices are sensitive to
electrostatic discharge (ESD) and can be damaged
Pins VC and VMODE should be set to zero before VDD by static electricity. Proper ESD control techniques
is ramped down. should be used when handling these HBM class 1A
devices.
4
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
0 0.0
-0.2
-10
-0.4
S21 (dB)
S21 (dB)
-20 -0.6
-0.8
-30
-1.0
-40 -1.2
0.0 0.5 1.0 1.5 2.0 2.5 3.0 0.0 0.5 1.0 1.5 2.0 2.5 3.0
Frequency (GHz) Frequency (GHz)
S11 S22
0 0
-10 -10
S22 (dB)
S11 (dB)
-20 -20
-30 -30
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 3.0 0.0 0.5 1.0 1.5 2.0 2.5 3.0
Frequency (GHz) Frequency (GHz)
5
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
S21 S21
-8 S11 -8 S11
S22 S22
S-Parameters (dB)
S-Parameters (dB)
-16 -16
-24 -24
-32 -32
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 3.0 0.0 0.5 1.0 1.5 2.0 2.5 3.0
Frequency (GHz) Frequency (GHz)
0 0
+25°C -2
-10 -40°C
+85°C
+120°C
-4
S21 (dB)
S21 (dB)
-20
+25°C
-6 -40°C
+85°C
+120°C
-30
-8
-40 -10
0.0 0.5 1.0 1.5 2.0 2.5 3.0 0.0 0.5 1.0 1.5 2.0 2.5 3.0
Frequency (GHz) Frequency (GHz)
6
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
S21 S21
-8 S11 -8 S11
S22 S22
S-Parameters (dB)
S-Parameters (dB)
-16 -16
-24 -24
-32 -32
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
V_Control (V) V_Control (V)
S11, S22, S21 @ 1.8 GHz, VMODE = 0 V S11, S22, S21 @ 1.8 GHz, VMODE = 2 V
0 0
S21 S21
-8 S11 -8 S11
S22 S22
S-Parameters (dB)
S-Parameters (dB)
-16 -16
-24 -24
-32 -32
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
V_Control (V) V_Control (V)
S11, S22, S21 @ 3 GHz, VMODE = 0 V S11, S22, S21 @ 3 GHz, VMODE = 2 V
0 0
S21 S21
-8 S11 -8 S11
S22 S22
S-Parameters (dB)
S-Parameters (dB)
-16 -16
-24 -24
-32 -32
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
7 V_Control (V) V_Control (V)
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
+25°C +25°C
-40°C -40°C
+85°C +85°C
-10 +120°C
-10 +120°C
S21 (dB)
S21 (dB)
-20 -20
-30 -30
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
V_Control (V) V_Control (V)
+25°C +25°C
-40°C -40°C
+85°C +85°C
-10 +120°C -10 +120°C
S21 (dB)
S11 (dB)
-20 -20
-30 -30
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
V_Control (V) V_Control (V)
+25°C
-40°C
+85°C
-10 +120°C
S22 (dB)
-20
-30
-40
0.0 0.5 1.0 1.5 2.0 2.5
V_Control (V)
8
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
60
40
50
30 Low
High 40
20 30
Low
20
High
10
10
0 0
0.5 1.0 1.5 2.0 0.5 1.0 1.5 2.0
V_Control (V) V_Control (V)
-10
5 MHz
2 GHz
S21 (dB)
-20
-30
-40
10.0 12.6 15.2 17.9 20.5 23.1 25.8 28.4 31.0
Input Power (dBm)
9
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
R1 1 kΩ 0402
C1 10 pF 0402
VMODE VC
C2 1 nF 0402
Application Schematic
VDD Supply
C2
Vertical BNC or SMA
VMODE (digital) R1 Connection
C1
VMODE VDD VC GND
16 15 14 13
GND 1 15 GND
GND 2 11 GND
To RF Connector To RF Connector
3 10
RFIN RFOUT
GND 4 9 GND
5 6 7 8
10
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
Typical Performance11:
Z0 = 50 Ω, Freq. = 3 GHz, TA = 25°C, VDD = +5.0 V, VMODE=0 V, PIN = 0 dBm (small signal)
11. Parameters are measured on a test board, which is de-embedded to the package pins. The high frequency data (>2 GHz) is obtained from
a 50 Ω board with wide band connectors.
11
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
-0.2
-10
-0.4
S21 (dB)
S21 (dB)
-20 -0.6
-0.8
-30
-1.0
-40 -1.2
0 1 2 3 4 5 6 0 2 4 6 8 10 12
Frequency (GHz) Frequency (GHz)
S11
S22
0 0
-10 -10
S22 (dB)
S11 (dB)
-20 -20
-30 -30
-40 -40
0 1 2 3 4 5 6 0 1 2 3 4 5 6
Frequency (GHz) Frequency (GHz)
S11 S11
S21 S21
-10 S22 -10 S22
S-Parameters (dB)
S-Parameters (dB)
-20 -20
-30 -30
-40 -40
0 1 2 3 4 5 6 0 1 2 3 4 5 6
Frequency (GHz) Frequency (GHz)
12
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
S-Parameters (dB)
S21
S21
S22
S22
-20 -20
-30 -30
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
Frequency (GHz) Frequency (GHz)
S11, S22, S21 @ 1.8 GHz, VMODE = 0 V S11, S22, S21 @ 1.8 GHz, VMODE = 2 V
0 0
-10 -10
S-Parameters (dB)
S-Parameters (dB)
-20 -20
S11 S11
S21 S21
-30 S22
-30 S22
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
Frequency (GHz) Frequency (GHz)
S11, S22, S21 @ 3 GHz, VMODE = 0 V S11, S22, S21 @ 3 GHz, VMODE = 2 V
0 0
-10 -10
S-Parameters (dB)
S-Parameters (dB)
-20 -20
S11 S11
S21 S21
-30 S22
-30 S22
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
Frequency (GHz) Frequency (GHz)
13
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
-10 -10
S21 (dB)
S21 (dB)
-20 -20
+25°C +25°C
-40°C -40°C
-30 +120°C -30 +120°C
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
Control Voltage (V) Control Voltage (V)
-10
S21 (dB)
-20
+25°C
-40°C
-30 +120°C
-40
0.0 0.5 1.0 1.5 2.0 2.5
Control Voltage (V)
14
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
0 0
-2
+25°C
-10 -40°C
+120°C
-4
S21 (dB)
S21 (dB)
-20
-6 +25°C
-40°C
+120°C
-30
-8
-40 -10
0 1 2 3 4 5 6 0 1.2 2.4 3.6 4.8 6
Frequency (GHz) Frequency (GHz)
S11 Over temp @ 1.8 GHz S22 Over temp @ 1.8 GHz
0 0
-10 -10
S11 (dB)
S22 (dB)
-20 -20
+25°C +25°C
-30 -40°C -30 -40°C
+85°C +85°C
+120°C +120°C
-40 -40
0.0 0.5 1.0 1.5 2.0 2.5 0.0 0.5 1.0 1.5 2.0 2.5
Frequency (GHz) Frequency (GHz)
15
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
†
Reference Application Note S2083 for lead-free solder reflow recommendations.
Meets JEDEC moisture sensitivity level 1 requirements.
Plating is 100% matte tin over copper
Revision History
Date
16
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.
THESE MATERIALS ARE PROVIDED "AS IS" WITH NO WARRANTY OR LIABILITY, EXPRESS OR IMPLIED,
RELATING TO SALE AND/OR USE OF MACOM PRODUCTS INCLUDING FITNESS FOR A PARTICULAR
PURPOSE, MERCHANTABILITY, INFRINGEMENT OF INTELLECTUAL PROPERTY RIGHT, ACCURACY OR
COMPLETENESS, OR SPECIAL, INDIRECT, INCIDENTAL, OR CONSEQUENTIAL DAMAGES WHICH MAY
RESULT FROM USE OF THESE MATERIALS.
MACOM products are not intended for use in medical, lifesaving or life sustaining applications. MACOM
customers using or selling MACOM products for use in such applications do so at their own risk and agree to fully
indemnify MACOM for any damages resulting from such improper use or sale.
17
MACOM Technology Solutions Inc. (MACOM) and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice.
Visit www.macom.com for additional data sheets and product information.