Professional Documents
Culture Documents
CPET Info Bluetooth Connection
CPET Info Bluetooth Connection
CPET Info Bluetooth Connection
1
Devices Driver name Compatible with Art. 12 V 2.19 V 2.21 ≥V 3.0 Note 1 Note 2
HR monitor
No ok* ok* ?? Windows 7
Polar WearLink (V 2.0)
BT SMART (V 4.0) No ok Recommend H7 and H10 Windows 10
Not possible
Note: OK* means that we did not re-test the device as there was no change in the software in this respect, or the system is compatible with already tested devices.
2
Additional notes and details
How to setup the Bluetooth connections
Make sure that the Bluetooth receiver is activated (or insert the Bluetooth USB-stick) and the Bluetooth icon is
visible in the toolbar or at least in the hidden icon field.
Do not install the driver delivered with the Bluetooth receiver CD
i. Select “Start”
3
b. Vyntus ECG
ii. Open the Bluetooth menu via the Bluetooth icon (or from taskbar):
iii. Push the ECG-button at least 3 seconds until the blue LED is blinking “fast”:
Note: The ECG must be in the “fast blinking mode” during the installation.
There is a timeout after 1 min (respectively 10 min with the newer versions) and the
ECG will switch off
4
vi. Select ”Enter … pairing code”
(Note: Bluetooth version V 2.1 does not need the pairing code anymore)
viii. Now the system is installing the drivers; if successful, press “close”
5
ix. Now wait until the clock disappears:
Installing: finished:
x. Done
Additional info: The ECG-connection will establish a COM-port, which you can see by selecting
the Vyntus ECG via the right mouse button and select the Hardware TAB:
However the ECG will be connected directly by the software via “Socket” and will not use a
COM-port.
Important note:
If the ECG is paired, never start the pairing mode on the ECG again.
• If you do this, the pairing will be lost!!
• In this case, you need to remove the Bluetooth device, re-boot the system, pair the
ECG again and test it again via the system configuration.
6
c. Polar Wearlink
ii. For the setup you need to put the Polar Belt onto a subject
iii. Open the Bluetooth menu via the Bluetooth icon (or from taskbar):
7
vi. Select ”Enter … pairing code”
viii. Now the system is installing the drivers; if successful, press “close”
ix. Now the system is installing the drivers – wait until the clock disappears:
8
Installing: finished:
x. Done
Additional info: The Polar-connection will establish a COM-port, which you can see by selecting
the Polar via the right mouse button and select the Hardware TAB:
However the Polar will be connected directly by the software via “Socket” and will not use a
COM-port.
xi. Done.
9
d. Connecting a Bluetooth SMART heart rate device to SentrySuite
You need SeS v3.0 and a Config License with BT SMART
1. Pair the Bluetooth SMART device with Windows 10 (wearing the chest belt)
Second: Click the “Test device” button (wearing the chest belt)
10
3. Configure the device within CPET application “Heartrate Bluetooth Smart”
11