Professional Documents
Culture Documents
Recruitment Test 2 - Piping Engineering
Recruitment Test 2 - Piping Engineering
(1) In the drawing at a scale of 1: 100, the measured value with a ruler was 100 mm.
Which of the following is right value?
a. 100mm b. 1,000mm c. 10,000mm d. 100,000mm
Question 2
Please describe the drawing type for the attached drawings.
And please explain what the drawing shows, purpose and use.
Drawing type Explanation
(1)
(2)
(3)
1/5
Question3
(1) Which of the following is the correct AutoCAD command required, when you want to
change form Figure A to Figure B?
a. TRIM b. EXTEND c. OFFSET d. HIDE
(2) Which of the following is the correct AutoCAD command required, If you want to set
a layout with different scales.
a. vport b .scale b .dim
(3) Which of the following is the correct valve used for flow control?
a. ball valve b. needle valve c. butterfly valve
(5) Which of the following is the correct position for mounting the resistivity sensor?
a. b. c.
2/5
Question 4-1
Fill in the missing lines in Figure c, referring to Figures a and b.
(1) (2)
Figure"c" Figure"c"
Question 4-2
Create a bird's-eye view based on the sketch below. (Please refer to the following example.)
example ) Answer
3/5
Question5-1
Draw an isometric drawing of the suction piping (red mark part) in the piping layout below.
This drawing purpose is to fabricate and installation
P.N
VP SGP(RL)
4/5
Question5-2
Draw a piping layout from the attached isometric drawing.
5/5