Professional Documents
Culture Documents
FRT 012
FRT 012
FR Series
GR Series Technical
Technical Bulletin
Bulletin 1 of
1
Brief
We inform you that optional EP-ROMs for short width papers(55~60mm) have been made.
Present Problems
Depending on the position of the paper or the paper feed tray, the paper may not pass through both,
paper and paper feed det, sensors. Mispassing the paper feed det sensor may cause paper jams, paper
feeding will not stabilize.( Mispassing the paper sensor will definitely cause paper jams.)
Program Modification
FRW/V1.11D (for FR39 series)
Even If the paper does not pass through the paper feed det sensor, the machine will disregard the paper
feed sensor, and the paper will be fed until a certain drum rotation degree( according to the setting of test
mode No.171). Therefore, the sag amount of the paper may be large.You can adjust this amount of sag by
setting test mode No.171(paper feed clutch deactivate timing). The setting range of test mode No.171 has
been modified as shown below.
Present ROM FRW/V1.11D
Test Mode No.171 setting range
155~165deg 130~165deg
If the paper passes through the paper feed det sensor, as usual, the paper will be fed as normal.
Important
Depending to the position of the paper or the paper feed tray, the paper may not pass through the paper
receiving sensors, installed to the suction unit. Therefore, a paper jam message will be indicated.
Part Number
for FR39 series 019-80069-008 FRW/V1.11D
for FR39 series 018-80030-007 FRM/V2.10D
Attached :