Professional Documents
Culture Documents
Troubleshooting Connection Table For Connector
Troubleshooting Connection Table For Connector
★ The pin No. is also marked on the connector (electric wire insertion end)
DT Series connector
Number
of Pins Body (plug) Body (receptacle) T-adapter Part
Number
8GR: 799-601-9060
8B: 799-601-9070
8 8G: 799-601-9080
8BR: 799-601-9080
Part number: 08192-1820 T (normal type) Part number: 08192-1810 T (normal type)
08192-2820 T (fine wire type) 08192-2810 T (fine wire type)
12GR: 799-601-9110
12B: 799-601-9120
10 12G: 799-601-9130
12BR: 799-601-9140
Part number: 08192-1920 T (normal type) Part number: 08192-1910 T (normal type)
08192-2920 T (fine wire type) 08192-2910 T (fine wire type)
D51EX/PX-22 40-143
TROUBLESHOOTING CONNECTION TABLE FOR CONNECTOR
★ The pin No. is also marked on the connector (electric wire insertion end)
DTM Series connector
Number of
Pins Body (plug) Body (receptacle) T-adapter Part
Number
2 799-601-9010
1 —
Part number: 08192-31200 (Contact size #12) Part number: 08192-31100 (Contact size #12)
08192-41200 (Contact size #8) 08192-41100 (Contact size #8)
08192-51200 (Contact size #4) 08192-51100 (Contact size #4)
40-144 D51EX/PX-22
TROUBLESHOOTING CONNECTION TABLE FOR CONNECTOR
12
DRC26 Series connector
No. of
pins T-adapter Part
Number
Body (plug) Body (receptacle)
24 799-601-9360
40
799-601-9350
(A)
40
799-601-9350
(A)
50 799-601-4210
⎯ ⎯
D51EX/PX-22 40-145
TROUBLESHOOTING T-ADAPTER TABLE
T-ADAPTER TABLE
★ The part Nos. of the T-adapter boxes and T-adapters are shown in the columns and those of the wiring harness checker
assemblies are shown in the lines.
KIT No.
799-601-2500
799-601-2700
799-601-2800
799-601-2900
799-601-3000
799-601-5500
799-601-6000
799-601-6500
799-601-7000
799-601-7100
799-601-7400
799-601-7500
799-601-8000
799-601-9000
799-601-9100
799-601-9200
799-601-9300
Port No. Connector type Pin No.
—
799-601-2600 For measuring box Econo-21P O O O O O O
799-601-3100 For measuring box MS-37P O
799-601-3200 For measuring box MS-37P O
799-601-3300 For measuring box Econo-24P O
799-601-3360 Plate For MS box
799-601-3370 Plate For MS box
799-601-3380 Plate For MS box
799-601-3410 BENDIX(MS) 24P O O
799-601-3420 BENDIX(MS) 24P O O
799-601-3430 BENDIX(MS) 17P O O
799-601-3440 BENDIX(MS) 17P O O
799-601-3450 BENDIX(MS) 5P O O
799-601-3460 BENDIX(MS) 10P O O
799-601-3510 BENDIX(MS) 5P O O
799-601-3520 BENDIX(MS) 14P O O
799-601-3530 BENDIX(MS) 19P O O
799-601-2910 BENDIX(MS) 14P O O
799-601-3470 CASE O
799-601-2710 MIC 5P O O O O
799-601-2720 MIC 13P O O O O
799-601-2730 MIC 17P O O O O O O O
799-601-2740 MIC 21P O O O O O O O
799-601-2950 MIC 9P O O O O
799-601-2750 ECONO 2P O O
799-601-2760 ECONO 3P O O
799-601-2770 ECONO 4P O O
799-601-2780 ECONO 8P O O
799-601-2790 ECONO 12P O O
799-601-2810 DLI 8P O O
799-601-2820 DLI 12P O O
799-601-2830 DLI 16P O O
799-601-2840 Extension cable O O O
799-601-2850 CASE O
799-601-4210 DRC 50 O
799-601-7010 X 1P O O
799-601-7020 X 2P O O O O
799-601-7030 X 3P O O O O
799-601-7040 X 4P O O O O
799-601-7050 SWP 6P O O O
799-601-7060 SWP 8P O O O
40-146 D51EX/PX-22
TROUBLESHOOTING T-ADAPTER TABLE
KIT No.
799-601-2500
799-601-2700
799-601-2800
799-601-2900
799-601-3000
799-601-5500
799-601-6000
799-601-6500
799-601-7000
799-601-7100
799-601-7400
799-601-7500
799-601-8000
799-601-9000
799-601-9100
799-601-9200
799-601-9300
Port No. Connector type Pin No.
—
799-601-7310 SWP 12P O
799-601-7070 SWP 14P O O
799-601-7320 SWP 16P O
799-601-7080 M 1P O O
799-601-7090 M 2P O O O O
799-601-7110 M 3P O O O O
799-601-7120 M 4P O O O O
799-601-7130 M 6P O O O O
799-601-7340 M 8P O
799-601-7140 S 8P O O O O
799-601-7150 S 10P-White O O O O
799-601-7160 S 12P-Blue O O O
799-601-7170 S 16P-Blue O O O O
799-601-7330 S 16P-White O
799-601-7350 S 12P-White O
799-601-7180 AMP040 8P O
799-601-7190 AMP040 12P O O
799-601-7210 AMP040 16P O O O O
799-601-7220 AMP040 20P O O O O
799-601-7230 Short connector X-2 O O O O
799-601-7240 Case O O
799-601-7270 Case O
799-601-7510 070 10P O
799-601-7520 070 12P O
799-601-7530 070 14P O
799-601-7540 070 18P O
799-601-7550 070 20P O
799-601-7360 Relay connector 5P O
799-601-7370 Relay connector 6P O
799-601-7380 JFC connector 2P O
799-601-9010 DTM 2P O O
799-601-9020 DT 2P O O
799-601-9030 DT 3P O O
799-601-9040 DT 4P O O
799-601-9050 DT 6P O O
799-601-9060 DT 8P-Gray O O
799-601-9070 DT 8P-Black O O
799-601-9080 DT 8P-Green O O
799-601-9090 DT 8P-Blown O O
799-601-9110 DT 12P-Gray O O
799-601-9120 DT 12P-Black O O
799-601-9130 DT 12P-Green O O
799-601-9140 DT 12P-Blown O O
799-601-9210 HD30 18-8 O O
D51EX/PX-22 40-147
TROUBLESHOOTING T-ADAPTER TABLE
KIT No.
799-601-2500
799-601-2700
799-601-2800
799-601-2900
799-601-3000
799-601-5500
799-601-6000
799-601-6500
799-601-7000
799-601-7100
799-601-7400
799-601-7500
799-601-8000
799-601-9000
799-601-9100
799-601-9200
799-601-9300
Port No. Connector type Pin No.
—
799-601-9230 HD30 18-20 O O
799-601-9220 HD30 18-14 O O
799-601-9240 HD30 18-21 O O
799-601-9250 HD24 24-9 O O
799-601-9260 HD30 2-16 O O
799-601-9270 HD30 24-21 O O
799-601-9280 HD30 24-23 O O
799-601-9290 HD30 24-31 O O
799-601-9310 Plate For HD30 O O O
799-601-9320 For measuring box For DT, HD O O O
799-601-9330 Case O
799-601-9340 Case O
799-601-9350 DEUTSCH 40P O
799-601-9360 DEUTSCH 24P O
799-601-9410 For NE, G sensor 2P O
799-601-9420 For boost pressure, fuel 3P O
799-601-9430 PVC socket 2P O
40-148 D51EX/PX-22
TROUBLESHOOTING T-ADAPTER TABLE
KIT No.
799-601-2500
799-601-2700
799-601-2800
799-601-2900
799-601-3000
799-601-5500
799-601-6000
799-601-6500
799-601-7000
799-601-7100
799-601-7400
799-601-7500
799-601-8000
799-601-9000
799-601-9100
799-601-9200
799-601-9300
Port No. Connector type Pin No.
—
799-601-9230 HD30 18-20 O O
799-601-9240 HD30 18-21 O O
799-601-9250 HD24 24-9 O O
799-601-9260 HD30 2-16 O O
799-601-9270 HD30 24-21 O O
799-601-9280 HD30 24-23 O O
799-601-9290 HD30 24-31 O O
799-601-9310 Plate For HD30 O O O
799-601-9320 For measuring box For DT, HD O O O
799-601-9330 Case O
799-601-9340 Case O
799-601-9350 DEUTSCH 40P O
799-601-9360 DEUTSCH 24P O
799-601-9410 For NE, G sensor 2P O
799-601-9420 For boost pressure, fuel 3P O
799-601-9430 PVC socket 2P O
D51EX/PX-22 40-149
TROUBLESHOOTING MODE CHART
12
MODE CHART
Troubleshooting mode
No. Error or possible phenomena Code
E-mode H-mode S-mode
display
1 Action codes are displayed on machine monitor Check error code
2 If error code display function is checked, error codes are displayed ●
Engine related problems
3 Engine does not start easily (Engine starting always takes time) S-1
4 Engine does not crank E-1 S-2a)
5 Engine does not start Engine cranks but no smoke comes out stack S-2b)
6 Smoke comes out stack but engine does not start S-2c)
7 Engine does not pickup smoothly (Poor follow up performance) S-3
8 Engine stops during operation S-4
9 Engine does not run smoothly (Hunts) S-5
10 Engine output is poor (lacks power) S-6
11 Exhaust smoke is black (incomplete combustion) S-7
12 Oil consumption is excessive (exhaust smoke is blue) S-8
13 Oil becomes contaminated quickly S-9
14 Fuel consumption is excessive S-10
15 Coolant contains oil (blows back or reduces) S-11
16 Oil pressure drops S-12
17 Oil level rises (Coolant or fuel in oil) S-13
18 Coolant temperature is too high (overheating) S-14
19 Abnormal noise is heard S-15
20 Vibration is excessive S-16
21 Preheat does not operate E-2
Power train related problems
Right and left travel systems do not operate in forward or reverse
22 H-1 S-6
(no travel system operates)
Right and left travel systems do not operate in forward or reverse
23 H-2
(only right or left travel system does not operate)
Right and left travel system do not operate in forward or reverse
24 H-3
(only one system does not operate)
25 Speed or power of travel is low H-4
26 Gear is not shifted H-5
27 Large shocks are felt when machine starts and stops travel H-6
28 Machine deviates greatly during travel H-7
29 Hydraulic drift of travel is great H-8
30 Engine stalls or engine speed lowers extremely during travel H-9
31 Abnormal sound comes out from around HST pump and motor H-10
32 HST oil temperature rises too high H-20
40-150 D51EX/PX-22
TROUBLESHOOTING MODE CHART
Troubleshooting mode
No. Error or possible phenomena Code
E-mode H-mode S-mode
display
Work equipment related problems
33 Work equipment does not operate at all E-21 H-11
34 Speed or power of all work equipment is low H-12
35 Speed or power of lifting the blade is low H-13
36 Speed or power of tilting the blade is low H-14
37 Speed or power of angling the blade is low H-15
38 Time lag in lifting the blade is great H-16
39 Hydraulic drift of lifting the blade is great H-17
40 Hydraulic drift of tilting the blade is great H-18
Abnormal sound comes out from around work equipment pump and
41 H-19
control valve
42 Hydraulic oil temperature raises too high H-20
Monitor panel related problems
43 When ignition switch is turned ON, nothing lights up E-3
44 Charge level caution lamp flashes while engine is running E-4
45 Emergency warning items flash while engine is running E-5
46 Preheat pilot lamp does not light up during preheat operation E-6
47 The coolant temperature gauge does not indicate correctly E-7
48 The HST oil temperature gauge does not indicate correctly E-8
49 Fuel level gauge does not indicate properly E-9
50 Travel lever speed shift mode indicator does not display correctly E-10
51 Multi-information unit does not display correctly E-11
52 Caution lamp does not flash or does not go off E-12
53 Caution buzzer does not sound or will not stop sounding E-13
54 Reverse travel speed setting switch does not function E-14
55 Shift mode switch does not function E-15
56 Buzzer cancel switch does not function E-16
57 Information switch does not function E-17
Other related items
58 Fan speed is abnormal (High, low or 0 rpm) H-21
59 The fan cleaning does not operate or cannot be reset E-18
60 Backup alarm does not sound E-19
61 The horn does not sound or does not stop sounding E-20
62 Head lamp or rear lamp does not light up E-22
63 Foot heater does not operate E-23
64 Air conditioner does not operate (Cab specification) E-24
65 Windshield wipers and washers do not operate (Cab specification) E-25
66 KOMTRAX system does not operate correctly E-26
D51EX/PX-22 40-151
40 TROUBLESHOOTING (BY ERROR CODE)
D51EX/PX-22 40-201
TROUBLESHOOTING
40-202 D51EX/PX-22
TROUBLESHOOTING
D51EX/PX-22 40-203
TROUBLESHOOTING
40-204 D51EX/PX-22
TROUBLESHOOTING TROUBLESHOOTING BY ERROR CODE
Action Buzzer
Error codes Defective part Trouble Mode Message Lamps History
code ON
ON
Mechanical
6091NX HST charge filter element Clogging HST — — • • system
Mechanical
AA10NX Air cleaner Clogging MON — — — —
system
Mechanical
AB00MA Alternator Malfunction MON — — • —
system
Mechanical
B@BAZG Engine oil Lowering of oil pressure ENG — — • • system
Mechanical
B@BCNS Coolant Overheat ENG — — • • system
Mechanical
B@CRNS HST oil Overheating HST — — • • system
Mechanical
B@CRZG HST oil Lowering of oil pressure HST — — • • system
CON- Electrical
CA111 Engine controller Abnormality in controller ENG E04
TROLLER
• • system
ENG Electrical
CA115 Abnormal engine NE, Bkup speed Abnormal speed sensor signal ENG E04
SPEED
• • system
Electrical
CA122 Charge pressure sensor too high Excessively high voltage detected ENG E03 ENGINE • • system
Electrical
CA123 Charge pressure sensor too low Excessively low voltage detected ENG E03 ENGINE • • system
DECEL Electrical
CA131 Decelerator pedal sensor too high Excessively high voltage detected ENG E03
PEDAL
• • system
DECEL Electrical
CA132 Decelerator pedal sensor too low Excessively low voltage detected ENG E03
PEDAL
• • system
Coolant temperature sensor too WATER Electrical
CA144
high
Excessively high voltage detected ENG E02
TEMP
• q
system
Coolant temperature sensor too WATER Electrical
CA145
low
Excessively low voltage detected ENG E02
TEMP
• • system
Charge temperature sensor too Electrical
CA153 Excessively high voltage detected ENG E01 ENGINE — —
high system
D51EX/PX-22 40-205
TROUBLESHOOTING TROUBLESHOOTING BY ERROR CODE
40-206 D51EX/PX-22
TROUBLESHOOTING TROUBLESHOOTING BY ERROR CODE
Electrical
CA553 Common rail pressure too high 1 Excessively high pressure detected ENG E02 ENGINE • q•
system
Electrical
CA559 Supply pump no pressure 1 No pressure feeding detected ENG E02 ENGINE • • system
ENG Electrical
CA689 Abnormal engine Ne speed sensor Abnormality in signal ENG E03
SPEED
• • system
Abnormal engine Bkup speed sen- ENG Electrical
CA731
sor phase
Abnormal phase ENG E03
SPEED
• • system
Loss of all data of engine control- CON- Electrical
CA757
ler
Loss of all data ENG E04
TROLLER
• • system
Abnormal engine Bkup speed sen- ENG Electrical
CA778
sor
Abnormal Bkup signal ENG E03
SPEED
• • system
Abnormal CAN communication
DATA Electrical
CA1633 (Engine controller – HST control- Abnormal communication ENG E03
LINK
• • system
ler)
Decelerator pedal sensor power DECEL Electrical
CA2185
source too high
Excessively high voltage detected ENG E03
PEDAL
• • system
Decelerator pedal sensor power DECEL Electrical
CA2186
source too low
Excessively low voltage detected ENG E03
PEDAL
• • system
Electrical
CA2249 Supply pump no pressure 2 No pressure feeding detected ENG E03 ENGINE • • system
Electrical
CA2311 Abnormal IMV solenoid Abnormal resistance ENG E03 ENGINE • • system
HEATER Electrical
CA2555 Open in air intake heater relay Open ENG E01 — —
RELAY system
Short circuit in air intake heater HEATER Electrical
CA2556 Short circuit ENG E01 — —
relay RELAY system
N SAFETY Electrical
D130KA Neutral safety relay Open HST E02
RELAY
• • system
N SAFETY Electrical
D130KB Neutral safety relay Short circuit HST E02
RELAY
• • system
“Defective communication
CAN communication (Monitor DATA Electrical
DAFRKR
panel – HST controller)
(Abnormality in objective compo- MON E03
LINK
• • system
nent system)”
“Defective communication
CAN communication (Monitor DATA Electrical
DAFRMC
panel – Engine controller)
(Abnormality in objective compo- MON E03
LINK
• • system
nent system)”
Electrical
DAJ000 HST controller Memory error HST — — — —
system
BATTERY Electrical
DAJ0KK HST controller Lowing of source voltage HST E04
VOLTAGE
• • system
MACHINE Electrical
DAJ0KQ HST controller Machine code error HST E03
CODE
• • system
CON- Electrical
DAJ0KT HST controller Memory error HST E03
TROLLER
• • system
HST controller sensor 5V power SENSOR Electrical
DAJ5KK
supply No. 1
Lowing of source voltage/Input HST E04
VOLTAGE
• • system
HST controller sensor 5V power SENSOR Electrical
DAJ6KK
supply No. 2
Lowing of source voltage/Input HST E03
VOLTAGE
• • system
“Defective communication
CAN communication (HST con- DATA Electrical
DAJRKR
troller – Monitor panel)
(Abnormality in objective compo- HST E03
LINK
• • system
nent system)”
“Defective communication
CAN communication (HST con- DATA Electrical
DB2RKR
troller – Engine controller)
(Abnormality in objective compo- HST E03
LINK
• • system
nent system)”
SHIFT UP Electrical
DD12KA Shift up switch Open HST E02
SW
• • system
D51EX/PX-22 40-207
TROUBLESHOOTING TROUBLESHOOTING BY ERROR CODE
SHIFT UP Electrical
DD12KB Shift up switch Short circuit HST E02
SW
• • system
SHIFT Electrical
DD13KA Shift down switch Open HST E02
DOWN SW
• • system
SHIFT Electrical
DD13KB Shift down switch Short circuit HST E02
DOWN SW
• • system
TRAVEL Electrical
DD14KB Travel lock limit switch 1 Short circuit HST E03
LOCK
• • system
Electrical
DD1NL4 Fan rotation selector switch Disagreement of ON/OFF signals HST E01 FAN SW — —
system
R SPEED Electrical
DDDCKB Reverse travel speed switch Short circuit HST E01 — —
SW system
BRAKE Electrical
DDP6KA Brake oil pressure sensor Open HST E02
PRESS
• • system
BRAKE Electrical
DDP6KB Brake oil pressure sensor Short circuit HST E02
PRESS
• • system
BRAKE Electrical
DDP6MA Brake oil pressure sensor Malfunction HST E02
PRESS
• • system
TRAVEL Electrical
DDQ2KA Travel lock limit switch 1 Open HST E03
LOCK
• • system
SHIFT Electrical
DDT0L4 Shift mode switch Disagreement of ON/OFF signals HST E01 — —
MODE SW system
TRAVEL Electrical
DDU1FS Travel lock limit switches 1 and 2 Fixing HST E03
LOCK
• • system
TRAVEL Electrical
DDU1KA Travel lock limit switch 2 Open HST E03
LOCK
• • system
Short circuit with power supply TRAVEL Electrical
DDU1KY Travel lock limit switch 2
line
HST E03
LOCK
• • system
Electrical
DGS1KA HST oil temperature sensor Open HST E01 OIL TEMP — —
system
Electrical
DGS1KX HST oil temperature sensor Out of input signal range HST E01 OIL TEMP — —
system
HST Electrical
DHH5KA Left HST pump pressure sensor Open HST E02
PRESS
• • system
HST Electrical
DHH5KB Left HST pump pressure sensor Short circuit HST E02
PRESS
• • system
HST Electrical
DHH6KA Right HST pump pressure sensor Open HST E02
PRESS
• • system
HST Electrical
DHH6KB Right HST pump pressure sensor Short circuit HST E02
PRESS
• • system
FUEL Electrical
DK10KA Fuel dial sensor Open HST E03
DIAL
• • system
FUEL Electrical
DK10KB Fuel dial sensor Short circuit HST E03
DIAL
• • system
Electrical
DK30KA Steering angle sensor 1 Open HST E03 ST LEVER • • system
Electrical
DK30KB Steering angle sensor 1 Short circuit HST E03 ST LEVER • • system
Electrical
DK30KX Steering angle sensor Out of input signal range HST E04 ST LEVER • • system
Electrical
DK30KZ Steering angle sensor Open or short circuit HST E04 ST LEVER • • system
Electrical
DK30L8 Steering angle sensor Disagreement of analog signals HST E03 ST LEVER • • system
Electrical
DK31KA Steering angle sensor 2 Open HST E03 ST LEVER • • system
40-208 D51EX/PX-22
TROUBLESHOOTING TROUBLESHOOTING BY ERROR CODE
Electrical
DK31KB Steering angle sensor 2 Short circuit HST E03 ST LEVER • • system
BRAKE Electrical
DK40KA Brake pedal sensor Open HST E03
PEDAL
• • system
BRAKE Electrical
DK40KB Brake pedal sensor Short circuit HST E03
PEDAL
• • system
Electrical
DK55KX Directional potentiometer Out of input signal range HST E04 FR LEVER • • system
Electrical
DK55KZ Directional potentiometer Open or short circuit HST E04 FR LEVER • • system
Electrical
DK55L8 Directional potentiometer Disagreement of analog signals HST E03 FR LEVER • • system
Electrical
DK56KA Directional potentiometer 1 Open HST E03 FR LEVER • • system
Electrical
DK56KB Directional potentiometer 1 Short circuit HST E03 FR LEVER • • system
Electrical
DK57KA Directional potentiometer 2 Open HST E03 FR LEVER • • system
Electrical
DK57KB Directional potentiometer 2 Short circuit HST E03 FR LEVER • • system
TRAVEL Electrical
DLM0KX HST motor speed sensor Out of input signal range HST E03
SPEED
• • system
TRAVEL Electrical
DLM1KA Left HST motor speed sensor Open HST E01 — —
SPEED system
Electrical
DLM1KB Left HST motor speed sensor Short circuit HST — — — —
system
Electrical
DLM1MA Left HST motor speed sensor Malfunction HST — — — —
system
TRAVEL Electrical
DLM2KA Right HST motor speed sensor Open HST E01 — —
SPEED system
Electrical
DLM2KB Right HST motor speed sensor Short circuit HST — — — —
system
Electrical
DLM2MA Right HST motor speed sensor Malfunction HST — — — —
system
FAN Electrical
DLM3KA Fan speed sensor Open HST E01 — —
SPEED system
FAN Electrical
DLM3KB Fan speed sensor Short circuit HST E02
SPEED
• • system
BRAKE Electrical
DN21FS Brake pedal and proximity switch Fixing HST E03
PEDAL
• • system
Electrical
DV00KB Caution buzzer Short circuit MON E01 BUZZER — —
system
BACK Electrical
DV20KB Back alarm buzzer Short circuit HST E01 — —
ALARM system
P BRAKE Electrical
DW4BKA Parking brake solenoid valve Open HST E04
SOL
• • system
P BRAKE Electrical
DW4BKB Parking brake solenoid valve Short circuit HST E04
SOL
• • system
Short circuit with power supply P BRAKE Electrical
DW4BKY Parking brake solenoid valve
line
HST E03
SOL
• • system
FAN CLN Electrical
DW7BKA Fan reverse solenoid valve Open HST E01 — —
SOL system
FAN CLN Electrical
DW7BKB Fan reverse solenoid valve Short circuit HST E01 — —
SOL system
Short circuit with power supply FAN CLN Electrical
DW7BKY Fan reverse solenoid valve
line
HST E03
SOL
• • system
D51EX/PX-22 40-209
TROUBLESHOOTING TROUBLESHOOTING BY ERROR CODE
SLOW
Electrical
DW7EKA Slow brake solenoid valve Open HST E04 BRAKE • • system
SOL
SLOW
Electrical
DW7EKB Slow brake solenoid valve Short circuit HST E04 BRAKE • • system
SOL
SLOW
Short circuit with power supply Electrical
DW7EKY Slow brake solenoid valve
line
HST E03 BRAKE • • system
SOL
Electrical
DWN5KA Fan EPC solenoid valve Open HST E01 FAN EPC — —
system
Electrical
DWN5KB Fan EPC Solenoid valve Short circuit HST E01 FAN EPC — —
system
Short circuit with power supply Electrical
DWN5KY Fan EPC solenoid valve
line
HST E02 FAN EPC • • system
LF HST pump EPC solenoid HST PUMP Electrical
DXA4KA
valve
Open HST E03
EPC
• • system
LF HST pump EPC solenoid HST PUMP Electrical
DXA4KB
valve
Short circuit HST E03
EPC
• • system
LF HST pump EPC solenoid Short circuit with power supply HST PUMP Electrical
DXA4KY
valve line
HST E04
EPC
• • system
LR HST pump EPC solenoid HST PUMP Electrical
DXA5KA
valve
Open HST E03
EPC
• • system
LR HST pump EPC solenoid HST PUMP Electrical
DXA5KB
valve
Short circuit HST E03
EPC
• • system
LR HST pump EPC solenoid Short circuit with power supply HST PUMP Electrical
DXA5KY
valve line
HST E04
EPC
• • system
RF HST pump EPC solenoid HST PUMP Electrical
DXA6KA
valve
Open HST E03
EPC
• • system
RF HST pump EPC solenoid HST PUMP Electrical
DXA6KB
valve
Short circuit HST E03
EPC
• • system
RF HST pump EPC solenoid Short circuit with power supply HST PUMP Electrical
DXA6KY
valve line
HST E04
EPC
• • system
RR HST pump EPC solenoid HST PUMP Electrical
DXA7KA
valve
Open HST E03
EPC
• • system
RR HST pump EPC solenoid HST PUMP Electrical
DXA7KB
valve
Short circuit HST E03
EPC
• • system
RR HST pump EPC solenoid Short circuit with power supply HST PUMP Electrical
DXA7KY
valve line
HST E04
EPC
• • system
HST
Left HST motor EPC solenoid Electrical
DXK1KA
valve
Open HST E02 MOTOR • • system
EPC
HST
Left HST motor EPC solenoid Electrical
DXK1KB
valve
Short circuit HST E02 MOTOR • • system
EPC
HST
Left HST motor EPC solenoid Short circuit with power supply Electrical
DXK1KY
valve line
HST E04 MOTOR • • system
EPC
HST
Right HST motor EPC solenoid Electrical
DXK2KA
valve
Open HST E02 MOTOR • • system
EPC
HST
Right HST motor EPC solenoid Electrical
DXK2KB
valve
Short circuit HST E02 MOTOR • • system
EPC
HST
Right HST motor EPC solenoid Short circuit with power supply Electrical
DXK2KY
valve line
HST E04 MOTOR • • system
EPC
Mechanical
6091NX HST charge filter element Clogging HST — — • • system
40-210 D51EX/PX-22
TROUBLESHOOTING TROUBLESHOOTING BY ERROR CODE
Mechanical
AA10NX Air cleaner Clogging MON — — — —
system
Mechanical
AB00MA Alternator Malfunction MON — — • —
system
Mechanical
B@BAZG Engine oil Lowering of oil pressure ENG — — • v
system
Mechanical
B@BCNS Coolant Overheat ENG — — • • system
Mechanical
B@CRNS HST oil Overheating HST — — • • system
Mechanical
B@CRZG HST oil Lowering of oil pressure HST — — • • system
CON- Electrical
CA111 Engine controller Abnormality in controller ENG E04
TROLLER
• • system
ENG Electrical
CA115 Abnormal engine NE, Bkup speed Abnormal speed sensor signal ENG E04
SPEED
• • system
Electrical
CA122 Charge pressure sensor too high Excessively high voltage detected ENG E03 ENGINE • • system
Electrical
CA123 Charge pressure sensor too low Excessively low voltage detected ENG E03 ENGINE • • system
DECEL Electrical
CA131 Decelerator pedal sensor too high Excessively high voltage detected ENG E03
PEDAL
• • system
DECEL Electrical
CA132 Decelerator pedal sensor too low Excessively low voltage detected ENG E03
PEDAL
• • system
Coolant temperature sensor too WATER Electrical
CA144
high
Excessively high voltage detected ENG E02
TEMP
• • system
Coolant temperature sensor too WATER Electrical
CA145
low
Excessively low voltage detected ENG E02
TEMP
• • system
Charge temperature sensor too Electrical
CA153 Excessively high voltage detected ENG E01 ENGINE — —
high system
Charge temperature sensor too Electrical
CA154 Excessively low voltage detected ENG E01 ENGINE — —
low system
SENSOR Electrical
CA187 Sensor power source 2 too low Excessively low voltage detected ENG E03
VOLTAGE
• • system
Atmospheric pressure sensor too Electrical
CA221
high
Excessively high voltage detected ENG E03 ENGINE • • system
Atmospheric pressure sensor too Electrical
CA222
low
Excessively low voltage detected ENG E03 ENGINE • • system
SENSOR Electrical
CA227 Sensor power source 2 too high Excessively high voltage detected ENG E03
VOLTAGE
• • system
Mechanical
CA234 Engine overspeed Excessively high speed ENG — — • • system
Abnormal power source for Ne ENG Electrical
CA238
speed sensor
Excessively low voltage detected ENG E03
SPEED
• • system
Electrical
CA271 IMV/PCV1 short circuit Short circuit ENG E03 ENGINE • • system
Electrical
CA272 IMV/PCV1 Open Open ENG E03 ENGINE • • system
Open and short circuit in injector Electrical
CA322
#1
Open or short circuit ENG E03 ENGINE • • system
Open and short circuit in injector Electrical
CA323
#5
Open or short circuit ENG E03 ENGINE • • system
Open and short circuit in injector Electrical
CA324
#3
Open or short circuit ENG E03 ENGINE • • system
Open and short circuit in injector Electrical
CA325
#6
Open or short circuit ENG E03 ENGINE • • system
D51EX/PX-22 40-211