Professional Documents
Culture Documents
Internship Report - 3
Internship Report - 3
In automation studio there are more virtual systems and choose one
of them it's about automatic electroplating system. In this there are
6 station and moving motor are there that used to take plate and
moving up down and also dip in the water or chemical. And after 5
station it unload this plate. This process simulation we did.
Output : station 1 to 6
up, down
in this project there are one conveyer that two buttons are there
one for forward and other for reverse. And one indicator light Is
there it blink when sensor its activated.
Here , Input : forward
reverse
output : sensor 1
sensor2
sensor 3
Here shared screen shot of this project
conveyor is in a place where the product will move from one end to
the other. The products are placed into the conveyor using an
actuator. The product is of two different types. One is conductive
(metallic) and the other is nonconductive (non-metallic). The middle
of the conveyor consists of a proximity switch that detects the
presence of the conductive product. Once the Sensors detect the
presence of the metal product, the second actuator pushes the
product to box 1. If the nonmetallic product crosses the sensor the
presence is not detected so the actuator will not extend. The
nonmetal product will then travel till the end of the conveyor belt
and falls into box 2.
Input : cylinder A
Cylinder B
Working process: A+A-B+B-
New Section 3 Page 4
Working process: A+A-B+B-
Here shared screen shot of this project
thank you