Professional Documents
Culture Documents
Hola Systems - Door Open Function
Hola Systems - Door Open Function
Hola Systems - Door Open Function
6mm
On the back side you need to open the back door. For this you need Hex key 2mm. Back at the
bottom of the case it is necessary to drill a hole through which the cable will pass. On the right image
you can see the place of cable installation inside the device.
smart and touch systems | hola.rs
After the rear door is removed it is necessary to remove the GREEN connector as in the picture. Use a thin
screwdriver to separate the left part of the connector (step1). Then the right part of the connector must be
removed (step2). When the connector starts to come out down, it needs to be removed easily (step 3 and step4).
Step 1. Step 2.
Step 3. Step 4.
after you have removed the connector, you need to screw the cable in the places as in the picture. These two
connectors are used to open a door or some other barrier.
smart and touch systems | hola.rs
On image bellow (step 5) you can see where the cable must be insert. On the picture on the right (step 6), the
cable is placed and the connector is ready to return to its place (step 7 and step 8).
Step 5. Step 6.
Step 7. Step 8.
IMPORTANT!!! On the next page are the device settings to turn on the "door open" option.
PLEASE CAREFULLY READ THE FOLLOWING TERMS AND CONDITIONS BEFORE USING
smart and
THE PRODUCT PROVIDED BY HOLA SYSTEMS. PLEASE CONTACT US touch
BEFOREsystems
ANY | hola.rs
ADDITIONAL DEVICE SETTINGS.
XȇȒȸƳƺȸɎȒƏƬƬƺɀɀɎǝƺƳƺɮǣƬƺƬȒȇˡǕɖȸƏɎǣȒȇȵǼƺƏɀƺȷɖǣƬǸǼɵɎƏȵɎǝƺ
upper screen edge multiple times while the device is currently
active.
ǔɎƺȸɎǝƏɎًɎǝƺȅƺɀɀƏǕƺƫȒɴɀǝȒɖǼƳƏȵȵƺƏȸًƏɀǸǣȇǕɵȒɖǔȒȸɎǝƺȵƏɀɀɯȒȸƳًǝƺȸƺɵȒɖ
ȇƺƺƳɎȒƺȇƳƺȸٺהדגבאٹƏɀȵƏɀɀɯȒȸƳِÁǝǣɀȒȵƺȇɀɎǝƺƳƺɮǣƬƺƬȒȇˡǕɖȸƏɎǣȒȇȵƏȇƺǼƏȇƳ
After that, the message box should appear, asking you for the password, here you need to ender “rakinda” as
ȵȸƺɀƺȇɎɀɵȒɖɯǣɎǝɎǝƺǔȒǼǼȒɯǣȇǕȒȵɎǣȒȇɀِ
password. This opens the device configuration panel and presents you with the following options.