Professional Documents
Culture Documents
Reflector Bulletin Split Reflector Assembly
Reflector Bulletin Split Reflector Assembly
Rev B
Installation Instructions
NOTE:
TOP
I. Confirm serial numbers are identical on each
reflector half and mounting ring.
Serial
number on
edge of joint
paltes
ECO 5081200
3
NOTE: Install 6 location bolts and lock nut in
splice plate, 3 on each side of feed hole
Splice plate
Special lack
nut, sst.
Feed hole
4
NOTE 1: Install and tighten 4 alignment bolts
at locations shown, 2 at each joint plate. bolts
should insert easily by hand, remove paint
form holes if necessary.
M8 hex nut
Lock washer
M8x30mm Lg. Alignment
bolts, sst.
Flat washer
Seam gap
6
NOTE: Attach mount ring, aligning red line match marks,
using M8 button head screws, as shown. Tighten hardware
inone direction, around mounting ring. (Seam is hsown Red line
vertical. It may be at 45deg. relative to top for some match marks
reflectors)
Lock washer
Flat washer
Andrew Corporation Telephone: 708/349-3300 Customer Service, 24 hours: U.S.A. • Canada • Mexico: 1-800/255-1479
10500 West 153rd Street FAX (U.S.A.): 1-800/349-5444 U.K.: 0800 250055 • Republic of Ireland: 1 800 535358
Orland Park, IL U.S.A. 60462 Internet: http://www.andrew.com Other Europe: +44 1592 782612
Hereby ANDREW, a Commscope Company, declares that this antenna is in compliance with the essential requirements of EU Directive 1999/5/EC. A
copy of the Declaration of Conformance is available on www.ANDREW.com.