Professional Documents
Culture Documents
Repair Procedure
Repair Procedure
Cut repair patch from a roll of PERP, approximately 50mm larger in each direction than
the area to be repaired.
Lightly abrade the area all around the damage with a scotch brite pad or fine abrasive
paper.
If damage is deep down to the steel, the void area should be filled with S1137 filler
mastic.
Abrade area extending at least 25mm beyond the area to be covered by the PERP repair
patch.
Preheat the damaged area with a propane torch with a gentle flame to 70 C to 90°C.
Preheat the PE repair patch with a propane flame on the adhesive side till soft and shiny.
While adhesive is still soft, apply the patch centrally over the damaged area,
Carefully heat and roll the PERP patch with a roller until the surface becomes smooth,
and the adhesive is visible all around the PERP. When the adhesive is too viscous and
rolling becomes difficult, reheat the area again.
15. Heat Shrinkable Sleeve and 3LPE LINE COATING REPAIR Criteria:
Damaged 3LPE line coating or damaged heat shrinkable sleeve shall be repaired with repair
materials as per the following criteria:
AG-COVALENCE-HTLP80-S1401M - SWCC 15