Professional Documents
Culture Documents
Alternator - Remove and Install (SENR1126-36)
Alternator - Remove and Install (SENR1126-36)
Removal Procedure
PSP
202 -000A
07: 4/03/2 4FC7
NOTICE
Keep all parts clean from contaminants.
4
SEN 5:11+ 5
Contaminants may cause rapid wear and shortened component
life.
© 2 R112 08:00
024 6
Cat
erp
illa
r In
c.
Illustration 1 g00599021
Illustration 2 g00599024
1. Disconnect harness assemblies (2), (3), and (4) from alternator (5).
https://sis2.cat.com/#/print-preview/service/7d4c3069-e5ef-4ed0-87df-5ff78af95ff9 1/3
3/25/24, 3:45 PM SIS 2.0
2. Loosen adjusting nuts (1) in order to provide slack for the belt.
3. Remove nuts and washers (6) in order to remove belt guard (7).
5. Remove bolt (9) in order to disconnect the alternator from the adjusting rod.
6. Remove bolt (10) in order to disconnect the alternator from the support. Remove alternator (5).
Installation Procedure
NOTICE
Keep all parts clean from contaminants.
Illustration 3 g00599024
https://sis2.cat.com/#/print-preview/service/7d4c3069-e5ef-4ed0-87df-5ff78af95ff9 2/3
3/25/24, 3:45 PM SIS 2.0
Illustration 4 g00599021
1. Position alternator (5) on the support. Install bolts (9) and (10) in order to hold the alternator in
place. Do not tighten the bolts yet.
3. Adjust the belt tension according to Specifications, "Belt Tension Chart". To adjust the belt
tension, turn adjusting nuts (1). Tighten the adjusting nuts.
4. After the belt tension has been adjusted, install belt guard (7). Secure the belt guard to bolts (9)
and (10) with nuts and washers (6).
PSP-000A4FC7
2024/03/25
07:45:05+08:00
i01761982
© 2024 Caterpillar Inc.
https://sis2.cat.com/#/print-preview/service/7d4c3069-e5ef-4ed0-87df-5ff78af95ff9 3/3