Professional Documents
Culture Documents
Drawworks - Api Inspection & Overhauling
Drawworks - Api Inspection & Overhauling
Draw_works
Objective:
After successful completion of this article session the participant will have improved
knowledge of the drawworks inspection and overhauling.
https://www.linkedin.com/pulse/inspection-overhauling-procedures-drawworks-be-gme-mba 1/6
19/3/24, 13:39 DRAWWORKS - API INSPECTION & OVERHAULING
Remove all air, water and lubrication piping and inspect condition.
Remove braking system and brake bands, disassemble and inspect condition.
Remove sand reel brake system and brake bands, disassemble and inspect condition.
Metal Particle Inspection should be carried out on all disassembled shafts, braking system
and all load bearing areas in accordance with ASTM E-709.
https://www.linkedin.com/pulse/inspection-overhauling-procedures-drawworks-be-gme-mba 2/6
19/3/24, 13:39 DRAWWORKS - API INSPECTION & OVERHAULING
Assembling Procedures:
Drawworks shall be assembled installing new bearings, seals, gaskets and worn parts as the
parts list prepared by API inspector and Project Engineer-Mechanical.
Reassemble drum-shaft, install into drawworks frame and add shims as required for
alignment.
Reassemble transmission output shaft, install into drawworks frame and add shim as required
for alignment.
Reassemble transmission input shaft, install into drawworks frame and add shims as required
for alignment.
Reassemble the low drum drive shaft, install into drawworks frame and add shims as required
for alignment.
Reassemble the sand reel / catshaft, install into drawworks frame and add shim as required
for alignment.
Reassemble braking system, install onto drawworks and add shims as required for proper
operation.
Reassemble brake bands, install onto drumshaft and adjust to correct working position.
https://www.linkedin.com/pulse/inspection-overhauling-procedures-drawworks-be-gme-mba 3/6
19/3/24, 13:39 DRAWWORKS - API INSPECTION & OVERHAULING
Reassemble make-up and breakout catheads and test operation, install onto catshaft.
Reassemble drillers console with overhauled control valves, install and terminate connections
on drawworks.
Reassemble foot throttle control valve, install and terminate connections on drawworks.
Installed new motors A and B onto drawworks and align with input shaft.
Thank You.
How many years for the inspection intervals, what is the API reference for this, please
Recomendar · Responder
Recomendar · Responder
https://www.linkedin.com/pulse/inspection-overhauling-procedures-drawworks-be-gme-mba 4/6
19/3/24, 13:39 DRAWWORKS - API INSPECTION & OVERHAULING
Mecánica
What are the most important hydraulic system troubleshooting tools and techniques?
Inspección mecánica
How do you use instruments and standards to measure coating thickness and adhesion?
Ingeniería mecánica
What are the pros and cons of welding vs. patching an exhaust leak?
Mecánica
Operaciones de fabricación
How can you ensure welding processes are safe and high-quality?
Mostrar más
https://www.linkedin.com/pulse/inspection-overhauling-procedures-drawworks-be-gme-mba 5/6
19/3/24, 13:39 DRAWWORKS - API INSPECTION & OVERHAULING
Mostrar más
© 2024 Acerca de
Idioma
https://www.linkedin.com/pulse/inspection-overhauling-procedures-drawworks-be-gme-mba 6/6