Professional Documents
Culture Documents
Ch.1 Reinforcement Details For Flat Slab 5
Ch.1 Reinforcement Details For Flat Slab 5
(1) Half of the width of column strip = min ( )/4 (Fig. 1)
(2) If ≠ then width of column strip =
Column
Strip
Middle
Strip
Fig. 2 Section
- 1 -
2) Plan (Example)
∎Note 1: Use solid lines for top bars and dotted lines for bottom bars
∎Note 2: A #4 bar means 4/8 inch diameter bar (which is D13)
A #3 bar means 3/8 inch diameter bar (which is D10)
∎Note 3: Arrangement of top and bottom bars must comply with Fig. 2.
Fig. 3 Plan
3) Edge columns
(a) Typical details for top bars at edge columns (flat plate)
- 2 -
(b) Typical details for top bars at corner columns (flat plate)
Fig. 4 Plan (exterior columns)
- 3 -