Professional Documents
Culture Documents
Jawel Paints Panel Wipe
Jawel Paints Panel Wipe
1.2. Relevant identified uses of the substance or mixture and uses advised against
Use of substance / mixture: Uses in coatings. Use in cleaning agents. Use in metal working fluids / Rolling oils. Use
as a functional fluid. Laboratories. Road and construction applications.
Classification under CLP: Flam. Liq. 2: H225; Asp. Tox. 1: H304; Skin Irrit. 2: H315; STOT SE 3: H336; Aquatic
Chronic 2: H411; -: EUH066
Most important adverse effects: Highly flammable liquid and vapour. May be fatal if swallowed and enters airways.
Causes skin irritation. May cause drowsiness or dizziness. Toxic to aquatic life with long
lasting effects. Repeated exposure may cause skin dryness or cracking.
Label elements:
Hazard statements: H225: Highly flammable liquid and vapour.
H304: May be fatal if swallowed and enters airways.
[cont...]
SAFETY DATA SHEET
PANELWIPE 3
Page: 2
H315: Causes skin irritation.
H336: May cause drowsiness or dizziness.
H411: Toxic to aquatic life with long lasting effects.
EUH066: Repeated exposure may cause skin dryness or cracking.
Hazard pictograms: GHS02: Flame
GHS08: Health hazard
GHS09: Environmental
GHS07: Exclamation mark
3.1. Substances
Skin contact: Remove all contaminated clothes and footwear immediately unless stuck to skin. Wash
immediately with plenty of soap and water.
Eye contact: Immediately flood the eye with plenty of water for at least 15 minutes,holding the eye
open. Remove any contact lenses and open eyes wide apart. Get medical attention if
any discomfort continues
Ingestion: Wash out mouth with water. Consult a doctor.
[cont...]
SAFETY DATA SHEET
PANELWIPE 3
Page: 3
Inhalation: Remove from exposure, rest and keep warm. In severe cases, or if recovery is not rapid
or complete, seek medical advice.
4.2. Most important symptoms and effects, both acute and delayed
Skin contact: There may be irritation and redness at the site of contact.
Eye contact: There may be irritation and redness. The eyes may water profusely.
Ingestion: There may be soreness and redness of the mouth and throat.
Inhalation: There may be irritation of the throat with a feeling of tightness in the chest. Exposure may
cause coughing or wheezing.
Delayed / immediate effects: Immediate effects can be expected after short-term exposure.
4.3. Indication of any immediate medical attention and special treatment needed
Immediate / special treatment: Eye bathing equipment should be available on the premises.
Extinguishing media: Alcohol resistant foam. Water spray. Carbon dioxide. Dry chemical powder. Use water
spray to cool containers.
Exposure hazards: Highly flammable. In combustion emits toxic fumes. Forms explosive air-vapour mixture.
Vapour may travel considerable distance to source of ignition and flash back.
Advice for fire-fighters: Wear self-contained breathing apparatus. Wear protective clothing to prevent contact
with skin and eyes.
Personal precautions: Refer to section 8 of SDS for personal protection details. If outside do not approach from
downwind. If outside keep bystanders upwind and away from danger point. Mark out the
contaminated area with signs and prevent access to unauthorised personnel. Turn
leaking containers leak-side up to prevent the escape of liquid. Eliminate all sources of
ignition.
Environmental precautions: Do not discharge into drains or rivers. Contain the spillage using bunding.
Clean-up procedures: Absorb into dry earth or sand. Transfer to a closable, labelled salvage container for
disposal by an appropriate method. Do not use equipment in clean-up procedure which
may produce sparks.
[cont...]
SAFETY DATA SHEET
PANELWIPE 3
Page: 4
Handling requirements: Avoid direct contact with the substance. Ensure there is sufficient ventilation of the area.
Do not handle in a confined space. Avoid the formation or spread of mists in the air.
Smoking is forbidden. Use non-sparking tools.
Storage conditions: Store in a cool, well ventilated area. Keep container tightly closed. Keep away from
sources of ignition. Prevent the build up of electrostatic charge in the immediate area.
Ensure lighting and electrical equipment are not a source of ignition.
Suitable packaging: Original container stored in a dry and cool place.
Hazardous ingredients:
HYDROCARBONS,C7-C9,N-ALKANES,ISOALKANES,CYCLICS
DNEL/PNEC Values
PANELWIPE 3
[cont...]
SAFETY DATA SHEET
PANELWIPE 3
Page: 5
Hazardous ingredients:
HYDROCARBONS,C7-C9,N-ALKANES,ISOALKANES,CYCLICS
Engineering measures: Ensure there is sufficient ventilation of the area. Ensure lighting and electrical
equipment are not a source of ignition.
Respiratory protection: If exposure levels are likely to be exceeded,use a full face mask fitted with an organic
AXP3 filter for short term low level exposures.For long term or high level
exposures,compressed airline breathing apparatus should be used.
Hand protection: Acceptable glove barrier materials include:Butyl rubber,Rubber (natural latex).Nitrile
rubber.Polyvinyl alcohol (PVA).It should be noted that liquid may penetrate the
gloves,frequent changes are recommended.
Eye protection: Safety goggles. Safety glasses. Ensure eye bath is to hand.
Skin protection: Chemical resistant protective clothing according to DIN EN13034 (Type 6)
State: Liquid
Colour: Colourless
Odour: Paraffinic
Evaporation rate: No data available.
Oxidising: No data available.
Solubility in water: Insoluble
Also soluble in: Most organic solvents.
Viscosity: No data available.
Kinematic viscosity: <7mm2/s@40
Boiling point/range°C: 100-125 Melting point/range°C: < -20
Flammability limits %: lower: 0.8 upper: 6.8
Flash point°C: -7 Part.coeff. n-octanol/water: No data available.
Autoflammability°C: >220 Vapour pressure: <31hPa@20C
Relative density: 0.730 pH: No data available.
VOC g/l: No data available.
[cont...]
SAFETY DATA SHEET
PANELWIPE 3
Page: 6
10.1. Reactivity
Hazardous reactions: Hazardous reactions will not occur under normal transport or storage conditions.
Decomposition may occur on exposure to conditions or materials listed below.
Skin contact: There may be irritation and redness at the site of contact.
Eye contact: There may be irritation and redness. The eyes may water profusely.
Ingestion: There may be soreness and redness of the mouth and throat.
Inhalation: There may be irritation of the throat with a feeling of tightness in the chest. Exposure may
cause coughing or wheezing.
Delayed / immediate effects: Immediate effects can be expected after short-term exposure.
12.1. Toxicity
[cont...]
SAFETY DATA SHEET
PANELWIPE 3
Page: 7
Disposal operations: Transfer to a suitable container and arrange for collection by specialised disposal
company.
NB: The user's attention is drawn to the possible existence of regional or national
regulations regarding disposal.
14.1. UN number
UN number: UN3295
Transport class: 3
Packing group: II
[cont...]
SAFETY DATA SHEET
PANELWIPE 3
Page: 8
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
Chemical safety assessment: A chemical safety assessment has not been carried out for the substance or the mixture
by the supplier.
Other information
Other information: according to Regulation (EC) No. 1907/2006 (REACH) with its amendment Regulation
(EU) 2015/830
* indicates text in the SDS which has changed since the last revision.
Phrases used in s.2 and s.3: EUH066: Repeated exposure may cause skin dryness or cracking.
H225: Highly flammable liquid and vapour.
H304: May be fatal if swallowed and enters airways.
H315: Causes skin irritation.
H336: May cause drowsiness or dizziness.
H411: Toxic to aquatic life with long lasting effects.
Legal disclaimer: The above information is believed to be correct but does not purport to be all inclusive
and shall be used only as a guide. This company shall not be held liable for any
damage resulting from handling or from contact with the above product.
[final page]