Download as pdf or txt
Download as pdf or txt
You are on page 1of 16

IOP Conference Series: Earth and

Environmental Science

PAPER • OPEN ACCESS You may also like


- Identification of alteration zones using a
Assessment of Medical Geology from Major Landsat 8 image of densely vegetated
areas of the Wayang Windu Geothermal
Element Trilinear Diagrams Cl-SO4-HCO3 and Na- field, West Java, Indonesia
Kristian Edwin Salamba, Arie Naftali Hawu
Hede and Mohamad Nur Heriawan
K-Mg from Geothermal and Non-Geothermal
- Analysis and application of impedance
Springs; Case Study the Wayang Windu polar diagram and zstrike rose diagram of
magnetotellurics data in southern part of
Geothermal Area, West Java, Indonesia the Wayang Windu geothermal field
O R Rohayat, R A Wicaksono and Y Daud

- Wayang Wong Bali performance in era


To cite this article: R. Maria et al 2024 IOP Conf. Ser.: Earth Environ. Sci. 1293 012002 pandemic Covid 19
N M Ruastiti, I K Sudirga and I G Yudarta

View the article online for updates and enhancements.

This content was downloaded from IP address 36.93.151.226 on 23/02/2024 at 02:35


12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

Assessment of Medical Geology from Major Element Trilinear


Diagrams Cl- SO4-HCO3 and Na-K-Mg from Geothermal and
Non-Geothermal Springs; Case Study the Wayang Windu
Geothermal Area, West Java, Indonesia

R. Maria1, R Prasetio2, R.M Shoedarto1, H Nurohman1, A. Yuliyanti1, H.


Lestiana1, E.N. Dida1, Aminuddin1, and Y. Rahayudin3
1
Research Center for Geological Resources, National Research and Innovation
Agency. KST Samaun Samadikun, Bandung, 40135
2
Research Center for Radiation Process Technology, National Research and
Innovation Agency. Pasar Jumat, Jakarta
3
Polytechnic of Energy and Mining, Ministry of Energy and Mineral Resources, 14
Bandung 40211, Indonesia

Email: rizk002@brin.go.id
https://orcid.org/0000-0002-5659-7657

Abstract. Medical geology research involves the processes, deficiencies, and excessive exposure
of significant elements and minerals to present solutions to health problems. Minerals from
volcanic aquifers from geothermal and non-geothermal springs interest medical geology
research. Major elements in source rocks essential for our health come from the rocks beneath
the earth's surface. This study aims to evaluate the medical geology of major elements in the
water from volcanic aquifers in the Wayang Windu Geothermal Area. The methods used are
trilinear analysis of major elements, Piper diagram, and statistical analysis. We have investigated
six cold springs, four hot springs, and three dug wells surrounding the Wayang Windu
geothermal area. The results of hydrochemical study and field checking identified the location
of water sources that have potential uses in medical geology and balneotherapy. The primary
relationship elements in the Piper Diagram defined five major water types: CaCl, MgCl,
CaMgHCO3, and CaHCO3. Results from hydrochemical analyses, statistics, and trilinear
diagrams were used to identify springs suitable for medical geology and balneotherapy. Hot
springs with good health criteria that meet the balneotherapy requirements are found at locations
H1, H2, H3, and H4. Hydrochemical data shows that hot springs in several areas of Pangalengan
are suitable for bathing and body contact activities but not for drinking water. Cold springs at
locations C1, C2, C3, C4, C5, and C6 meet the drinking water criteria surrounding the Wayang
Windu geothermal area.

1. Introduction
The acquisition of precise geochemical data is of utmost importance in evaluating the potential health
implications arising from exposure to elevated concentrations of potentially hazardous substances, as
well as in identifying areas where the scarcity of vital elements in groundwater and soil may have an
impact on the well-being of both animals and humans [1]. Elements in groundwater that are important
for health can be classified into five types according to their sources and characteristics: geogenic

Content from this work may be used under the terms of the Creative Commons Attribution 3.0 licence. Any further distribution
of this work must maintain attribution to the author(s) and the title of the work, journal citation and DOI.
Published under licence by IOP Publishing Ltd 1
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

substances, anthropogenic contaminants, biogenic elements, pathogens, and emerging contaminants [2]
[3]. The association between groundwater quality and human health can enhance groundwater's visibility
as a critical resource. However, it is essential to acknowledge the existing knowledge gap about the
interconnectedness of these factors, which necessitates the need for interdisciplinary research efforts to
bridge this gap [4]. Examining knowledge gaps and future developments pertaining to the correlation
between groundwater quality and human health is paramount in contemporary discourse [5]. The field
of medical geology study focuses on investigating the effects of excessive or inadequate exposure to
essential elements and minerals to propose interventions for health-related issues [6] [7].
Medical geology research studies mineralization from volcanic aquifers and geothermal/non-
geothermal springs. According to [8], the rocks beneath the Earth's surface contain significant
constituents crucial for maintaining our health. Throughout history, springs and hot springs have been
utilized globally for various purposes, such as the consumption of potable water, therapeutic benefits,
and expediting the healing process [9]. Tectonically produced natural mineral water exhibits
hydrogeochemistry influenced by the lithology and mineral structure arrangement. This water contains
various elements, including magnesium, potassium, calcium, iron, and other trace elements, positively
affecting human health [10] [11]. The earliest documented utilization of geothermal resources can be
traced back to ancient times, when hot water was employed for bathing and medical practices, often
associated with traditional religious customs, as observed during the era of Hippocrates. The primary
advantages of hot springs reside in their therapeutic and curative properties for medical intervention
[12]. Researchers from several countries have extensively investigated the correlation between utilizing
natural factor therapy and developing healing bath concepts [13].
Cold and hot springs have historically played a significant role in traditional cultural practices related
to bathing, healing, and spiritual purification in various Asian countries, including China, India, and
Japan [14]. Numerous scholarly investigations have been undertaken on the subject of groundwater
therapy within the field of medical geology. These studies mainly focus on comparing the utilization of
mineral-rich groundwater in natural therapeutic approaches. Notable examples include the research
conducted by [15] [16] [1] [7] [17]. Recently, there has been a notable surge in global interest in natural
mineral waters. This heightened attention can be attributed to growing apprehensions surrounding the
quality of surface water, the potential health benefits associated with mineral waters, and the evolving
patterns of human lifestyles. According to a recent ecological review conducted by [9], springs play a
crucial role in preserving ecosystems that harbor diverse flora and fauna. These ecosystems rely on
groundwater flow to sustain their environmental conditions and riparian habitats.
According to [17], there is a prevailing belief among the Indonesian population regarding the health
benefits of hot water, as it is believed to possess a rich mineral content conducive to overall well-being.
However, it is worth noting that not all communities know that hot springs constitute an integral
component of the geothermal system. Prior research has established a positive association between
beneficial minerals and the possible health advantages of geothermal springs. Numerous medical
conditions can be effectively managed by utilizing diverse thermal springs containing vital minerals
known for their therapeutic properties, typically in hot springs [18]. Wayang Windu is a geothermal
region located in the province of West Java, Indonesia, characterized by its many hot and cold springs
with significant potential. Geological conditions and geological structures greatly influence the
hydrochemistry of springs' primary constituents, offering potential for medical and geological therapy.
This study aims to examine the primary components of hydrogeochemical behavior in natural mineral
waters with varying lithological formations. The objective is to assess the field of medical geology using
major element trilinear diagrams of Cl-SO4-HCO3 and Na-K-Mg obtained from both geothermal and
non-geothermal springs. It is necessary to comprehend the hydrological and geochemical processes that
restrict the availability of natural mineral water sources. The present study aims to categorize various
types of water based on their hydrogeochemistry. Additionally, it seeks to determine the factors that
govern the presence of minerals in water and assess the hydrogeological and geochemical processes
involved. The research employs multivariate statistics and trilinear diagrams as analytical tools to
achieve these objectives. In this study, we conducted an investigation to examine the concept that the

2
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

lithological setting exhibits a strong correlation with natural mineral waters, which display distinct
physical and chemical characteristics in hydrogeochemical measurements obtained from various
springs.

2. Existing Geothermal Dryhouse


The research area is geographically situated inside the Bandung Basin region (see Figure 1). The
Bandung Basin can be described as a volcanic arc that occupies a valley situated between two mountain
ranges, with its underlying structure being connected to the Bogor Basin [19]. The research area is
situated inside the Bandung Zone, which is physiographically positioned in the central region of Java
Island [20].

Figure 1. Research location in Pangalengan, West Java, Indonesia

The Bogor Zone demarcates the northern boundary of the zone and is juxtaposed with the southern
mountain zone to the south. The Bandung Zone exhibits a higher level of economic depression compared
to the neighbouring zones, namely Bogor and the Southern Mountains Zone. The demarcation line
separating the Bandung Zone and the South Mountains is delineated by a sequence of volcanic
formations, namely Kendeng, Patuha, Tilu, Malabar, Papandayan, and Cikuray. A portion of the
Bandung Zone is characterized by the presence of volcanic and alluvial sediments, whereas the highlands
are predominantly composed of tertiary rock formations. The Quaternary volcanic chain encompasses
the geological region that spans the boundary between the elevated banks of the central portion of the
Southern Mountains and the Bandung Zone.
According to the regional geological maps of the Garut and Pameungpeuk sheets [21], the rock units
present in the research area are as follows: The Late Pleistocene (Qmt) Malabar-Tilu volcanic rock
groups are characterized by their composition, which primarily consists of tuff and lava breccias. These
rock units also contain minor quantities of pumice and lava. The breccias found in the local area are

3
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

relatively compact and cohesive. The geological formation under consideration is a volcanic deposit
from the late Pleistocene epoch. It is characterized by the presence of tuff rock, which has a fine-coarse
texture and is composed of dacitic material. Additionally, the deposit contains a tuffaceous breccia
consisting of pumice fragments and ancient lava deposits that display an andesitic-basalt composition.
The Waringin-Bedil Andesite Unit, located in the Old Malabar region, is classified as an Early
Pleistocene formation. This unit is characterized by a diverse rock composition, which includes
intercalated lava, breccia, and tuff. The rocks within this unit primarily consist of andesite, containing
minerals such as pyroxene, hornblende, and pumice. The study was carried out in the Wayang Windu
Pangelengan region, situated in the volcanic area of South Bandung, West Java, Indonesia. This location
is physically positioned between longitudes 107030'E – 107040'E and latitudes 7000'S - 7010' S (Figure
2).

Figure 2. The present document showcases a geological map of Pangalengan, a region located in West
Java, Indonesia. Modification from [21].

3. Methodology
The assessment of groundwater quality within the hydrogeologic system is conducted by analyzing
water samples collected from 13 specific spots. These sampling locations represent the diverse
groundwater and geological characteristics of the system. A comprehensive examination was conducted
on six cold springs, four hot springs, and three excavated wells in the vicinity of the Wayang Windu
geothermal area. This study utilized eleven laboratory variables to assess the groundwater quality for
medical geology investigations. These variables encompassed physical characteristics such as pH,
temperature, total dissolved solids (TDS), and electrical conductivity (EC), as well as chemical
components including sodium (Na+), potassium (K+), calcium (Ca2+), magnesium (Mg2+), chloride

4
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

(Cl-), sulfate (SO42-), and bicarbonate (HCO3-) concentrations at each water sample site. These
analyses can provide valuable insights in further elucidating the appropriate therapeutic approach.
The equipment employed for collecting, storing, and analyzing chemical components underwent
cleaning procedures with distilled water. The samples were gathered using a grab sampler throughout
the spring season. During the sampling process, additional water quality indicators, namely pH,
temperature, electric conductivity, and total suspended particles were assessed at the designated
collection sites. The pH was determined by employing a portable pH meter that was calibrated before to
each measurement. The instrument underwent calibration before its deployment in the field. The
chemical test of water samples was conducted at the E-service scientific laboratory, affiliated with the
National Research and Innovation Agency, BRIN. The trustworthiness of the chemical composition was
assessed through the application of charge balance procedures, as outlined by [22]. The parameters
encompass crucial cations, namely sodium (Na+), potassium (K+), calcium (Ca2+), and magnesium
(Mg2+), as well as anions such as sulfate (SO42-), chloride (Cl-), and bicarbonate (HCO3-). The
concentrations of sodium (Na+), potassium (K+), calcium (Ca2+), and magnesium (Mg2+) were
determined through the utilization of Atomic Absorption spectrometry (AAS). The estimation of
bicarbonate (HCO3-) was conducted by a titration method using H 2SO4, as described by [23]. The
chloride ions (Cl-) concentration was assessed by titration using standard AgNO3 solution. On the other
hand, the concentration of sulfate ions was studied using a spectrophotometer.
The employed techniques encompass a trilinear analysis of primary constituents, a Piper diagram,
and a bivariate study of main elements. The chloride (Cl-), sulfate (SO42-), and bicarbonate (HCO3-)
anions present in groundwater samples were graphed on a ternary diagram to ascertain the water
classification of hot springs and hydrothermal fluids, using hydro chemical concentrations as a basis.
The Cl--SO42--HCO3- triangle plotting diagram allows for the identification of four distinct categories of
geothermal fluid types: volcanic water, steam water hot, peripheral, and cooked water. The classification
of the geothermal fluid type is ascertained by quantifying the proportional distribution of the primary
anions present in the geothermal fluid, expressed as percentages. Subsequently, these values are
graphically represented on the Cl--SO42--HCO3- triangle diagram, as proposed by [24]. The Pearson
correlation coefficient is utilized to assess the association between the concentrations of the physico-
chemical parameters. The data analysis was conducted utilizing the SPSS Statistics 26 software. The
Pearson correlation coefficient results exhibited statistical significance and demonstrated a substantial
link among water parameters [25]. Cluster analysis is a valuable component of multivariate statistical
methods, as it facilitates the examination of geochemical patterns and the subsequent interpretation of
their hydrochemical features [26].

4. Result and Discussion


4.1. Physico-chemical Parameters
The present investigation methodically obtained 13 groundwater samples from various locations
surrounding the geothermal area. Figure 3 depicts the sample ID and concentration of physicochemical
parameters for all the groundwater samples. A Schoeller diagram to investigate patterns in the
concentration of anions and cations and to analyze the chemical composition of rock materials. The
different ways of three water groups (hot springs-H, cold springs-C, and dug wells-D).

5
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

1000

100
meq/L

10

0.1
Na K Ca Mg Cl SO4 HCO3
H1 66.81 14.86 46.62 83.96 9.34 87.38 589.22
H2 62.42 12.22 43.96 42.56 0.5 154.82 337.39
H3 79.64 22.08 60.02 61.7 0.81 28.56 760.36
H4 58.27 11.77 68.51 30.96 0.9 48.84 472.84
C1 4.84 1.63 8.08 5.85 8.26 5.27 35.21
C2 5.62 3.3 6.18 3.61 8.26 11.54 13.18
C3 5.09 1.23 12.03 7.27 9.64 87.38 589.22
C4 7.7 2.68 10.22 5.19 11.02 154.82 337.39
C5 8.74 1.31 5.97 3.88 8.92 28.56 760.36
C6 5.52 2.89 9.7 4.33 28.81 48.84 472.84
D1 9.14 2.27 8.08 3.96 38.57 1.28 10.54
D2 6.88 1.24 12.52 6.86 26.7 15.61 36.51
D3 9.14 14.46 9.48 6.83 41.32 25.59 13.18

Figure 3. The different patterns of three water groups (hot springs-H, cold springs-C, and dug wells-
D) are shown in a Schoeller diagram.
Table 1 summarizes the concentrations of main ions in the springs of the Wayang Windu area,
compared to the standards set by the World Health Organization [27]. The presence of many critical
constituents in drinking water is a matter of concern from a public health perspective due to the
possibility of exceeding suggested thresholds. Nevertheless, specific crucial components are essential
for maintaining good health and must be present in drinking water in precise amounts.
The concentrations of major ions compared to WHO Standard [27] in the springs of the Wayang
Windu area are summarized in Table 1. Most major elements in drinking water are apprehension from
a community health point of view because of the potential for excess above recommended limits.
However, some major elements are essential to health and must be present at specific concentrations in
drinking water.

Table 1. Physico-chemical parameters from Wayang Windu samples compared to WHO Standard
Parameter min (mg/L) max(mg/L) average(mg/L) Stdev(mg/L) [27]

pH 5.19 7.34 6.31 0.70 6.5

Temp 22 68.6 32.92 15.24

Cond 80 1180 429.23 378.10 1000

6
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

TDS 53 935.56 328.56 305.85 1000

Na+ 4.84 79.64 25.37 28.00 200

K+ 1.23 22.08 7.07 6.76 12

Mg2+ 3.61 83.96 20.54 25.44 50

Ca2+ 5.97 68.51 23.18 21.86 75

Cl- 0.5 41.32 14.85 13.56 250

SO42- 1.28 154.82 31.06 42.50 250

HCO3- 10.54 760.36 190.75 248.73 120

Total dissolved solids (TDS) and conductivity are derived from environmental factors, including
geological conditions and the impact of human activities such as using fertilizers, household practices,
and agricultural operations [28]. In the local context, the elevated Total Dissolved Solids (TDS) levels
during the dry season can be attributed to the evaporation process and the lack of a diluting mechanism.
The decrease in mineral content observed in groundwater during the rainy season might be attributed to
the dilution caused by the influx of rainwater, as discussed by [29]. The extent of rock-water reactions
is influenced by the hydrogeological features of rocks [30].
Sodium (Na+) is frequently observed inside igneous rocks in volcanic regions [31]. Its presence can
be attributed to the process of silicate weathering, which results in the formation of residual materials
within clay minerals [32]. The concentration of sodium ions (Na+) in Wayang Windu varied between
4.84 mg/l and 79.64 mg/l, whereas the concentration of potassium ions (K +) ranged from 1.23 mg/l to
22.08 mg/l, as shown in Table 1. According to [33], excessive consumption of sodium (Na+) has a
detrimental impact on individuals with hypertension and pregnant women with toxemia. The body's
ability to retain water depends on a significant quantity of sodium (Na +) and potassium (K+) ions. The
main goal of heart failure treatment is to reduce the concentration of Na + in the blood and promote water
excretion from the body [34].
The regulation of various physiological processes in the human body, such as blood vessel
contraction, blood coagulation, nerve transmission, and muscle contraction, is attributed to calcium ions
(Ca2+) [33]. The calcium ion (Ca2+) concentrations varied between 5.97 mg/l and 68.51 mg/l, as indicated
in Table 1. In natural environments, magnesium ions (Mg 2+) can be attributed to volcanic rocks
characterized by basaltic to andesitic compositions [35]. The magnesium ion (Mg2+) concentrations span
a range of 3.61 mg/l to 83.96 mg/l, as seen in Table 1. According to [36], the presence of insufficient
levels of magnesium in the body can lead to several health hazards, including atherosclerotic vascular
disease, eclampsia in pregnant women, vasoconstriction, acute myocardial infarction, infection, and
hypertension. The elevated levels of HCO3- in groundwater in various locations can be attributed to the
ample availability of CO2 resulting from gas dissolution and the infiltration of precipitation seepage [35]
[37]. The range of HCO3- levels observed in this study varied from 10.54 mg/l to 760.36 mg/l.
The elevated concentration of chloride ions (Cl -) in the central facies is subject to influence from
anthropogenic and hydrothermal activities, as discussed by [38]. The chloride (Cl-) concentrations varied
between 0.5 mg/l and 41.32 mg/l. Sulfate ions (SO 42-) are derived from various sources, including
mineral weathering, volcanic activity, leaching of fertilizers from agricultural soils, and industrial
wastewater runoff [39]. The concentrations of SO42- ions varied between 1.28 mg/l and 154.82 mg/l.
Elevated levels of sulfate in water indicate water pollution, and the presence of high sulfate
concentrations in water has been associated with the potential to induce gastrointestinal irritation [33].

7
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

4.2. Statistical Analysis


Pearson analysis was carried out to determine the relationship among the concentrations of
physicochemical parameters [25]. Pearson analysis shows the correlation among hydrogeochemical
parameters (Table 2). Temperature strongly correlates with EC, Na+, K+, Mg2+, Ca2+ SO42-, and HCO3-.
EC strongly correlates with Na+, K+, Mg2+, Ca2+ SO42-, and HCO3-. EC also strongly correlates with
temperature, Na+, K+, Mg2+, Ca2+ SO42-, and HCO3-. It is also obvious that Na+ strongly correlates with
temperature, EC, K+, Mg2+, Ca2+ SO42-, and HCO3-. K+ strongly correlates with temp, EC, Na+, Mg2+,
Ca2+ SO42-, and HCO3-. Ca2+ strongly correlates with temperature, EC, Na+, K+, Mg2+, SO42-, and HCO3-
. Mg 2+ strongly correlates with temperature, EC, Na+, K+, Ca2+, and HCO3-. SO42- has a strong correlation
with temperature, EC, and Na+. HCO3- strongly correlates with temp, EC, Na+, K+, Ca2+, and Mg2+.
Physical parameters such as temperature and EC closely correlate to anions and cations.

Table 2. Pearson correlation matrix for the hydrochemical concentration.


pH Temp EC Na+ K+ Mg2+ Ca2+ Cl- SO42- HCO3-

pH 1.00
Temp 0.08 1.00
EC -0.04 0.92 1.00
Na+ 0.03 0.94 0.95 1.00
K+ -0.14 0.78 0.82 0.86 1.00
Mg2+ 0.07 0.97 0.90 0.92 0.80 1.00
Ca2+ 0.08 0.89 0.88 0.95 0.79 0.81 1.00
Cl- -0.46 -0.52 -0.45 -0.56 -0.25 -0.47 -0.57 1.00
SO42- 0.01 0.72 0.87 0.71 0.54 0.67 0.61 -0.39 1.00
HCO3- 0.10 0.93 0.86 0.97 0.85 0.93 0.93 -0.58 0.54 1.00

Cluster analysis effectively explores and interprets hydrochemical characteristics [26]. This method
uses hierarchical clusters to measure the distance between variable clusters [40]. In this study,
hydrochemical data with similar properties were clustered in a group, including Na +, K+, Ca2+, Mg2+, Cl-
, SO42-, and HCO3-, which was considered to evaluate the characteristics of groundwater using the
average linkage hierarchy method (Figure 4). Based on the dendrogram of the cluster analysis results,
there are two groups with hot and cold spring characteristics: Group A, with the hydrochemical parts of
the cold springs, can be used for drinking water for the community, and Group B, with the hydrochemical
features of the hot springs, can be used for medical geology therapy.

8
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

Figure 4. The dendrogram of the cluster analysis in the research area

4.3. Hydrogeochemical Characteristic


The hot spring H1, located on Mount Windu, is within a geological formation of Young Volcanic rock.
The hot spring located in H2, more precisely within Mount Wayang, is found within the geological
formation known as Andesite Waringin Bedil. The hot springs found at coordinates H3 and H4 are
within regions characterized by hot springs originating from old volcanic rock formations. The springs
demonstrate relatively low temperatures near Old Volcanic and Malabar Volcanic rock formations. The
findings from the laboratory examination of anion and cation concentrations in the Wayang Windu
geothermal fluid samples are depicted in Figure 5. The spring waters are categorized into different
categories based on their hydrochemical composition, namely CaCl, CaMgCl, CaMgHCO 3, and
CaHCO3. Water sources are subject to geological circumstances that might influence the same type of
water concentration. The CaCl facies type is found in Old Volcanic rock formations in the excavated
wells D1 and D2. The CaMgCl facies type is situated within the D3 excavated well in the geological
formation of Old Volcanic rock.
The chloride water found in the springs within the research area results from combining hydrothermal
fluids with connate water or formation water. The phenomenon of condensation in this region gives rise
to the formation of acid sulfate water. The ensuing condensate water may undergo mixing with meteoric
water or groundwater, leading to the formation of sulfate-bicarbonate water. The CaMgHCO3 facies type
is located within the cold springs C1, C2, C3, C4, C5, and C6, found in Old Volcanic Rock formations.
The CaHCO3 facies type is located within the cold springs H1, H2, and H3, Old Volcanic rock
formations. Bicarbonate water is attributed to combining hydrothermal fluids with meteoric water or
groundwater. The springs in the research area are similar to hot springs utilized for balneotherapy in
many nations. For instance, CaHCO3 water is employed in Latvia to treat gastrointestinal ailments, such
as hepatic insufficiency. The condition known as gout has been studied by [41]. Bicarbonate (HCO3−),

9
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

the primary anion, exhibits anti-acid properties, enhances pancreatic function, acts as a hepatoprotector,
and promotes the excretion of uric acid in urine.
Additionally, mineral water containing high levels of carbon dioxide (CO 2) exceeding 250 mg/L has
been found to aid digestion, as [42] noted. Korean spas utilize a specific variety of sulfide-sodium
chloride water to treat dermatitis as a sedative and address psoriasis, as documented by [43]. According
to [15], sulfur-based water is utilized in American spas to treat burns, respiratory ailments, skin
conditions, and rheumatic disorders.

Figure 5. The Piper Diagram describes the water type in the Wayang Windu geothermal area.

4.4. The type of water based on Geothermal Fluid


The relative content of subsurface fluid elements can be used to determine the fluid's chemical type,
flow type, and source. The maturity of geothermal manifestations can be selected from the elemental
content of Na+, K+, and Mg2+ by plotting the Na-K-Mg [44]-ternary diagram. Mg2+ is an element that
has a small concentration at high temperatures (0.01-0.1 ppm). The high concentration of Mg 2+ is
sourced from dilution by surface water with a high Mg 2+ content [45]. The fluid release process observed
at the research site exhibits the presence of immature Na+, K+, and Mg2+ ions in the water, suggesting a
combination of hydrothermal fluid and meteoric water (Figure 6a). The potential origin of sulfate, with
concentrations reaching up to 154.82 mg/L, is likely attributed to the formation of water inside the
sedimentary rock stratum. Before transitioning into a surface condition, the fluid experiences a dilution
process by incorporating meteoric water or groundwater.

10
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

Figure 6. (a) Ternary plots of Na-K-Mg for identifying water equilibrated with the host rocks and (b)
Cl- - HCO3- - SO42- for classifying geothermal water.
The relative contents of Cl-, SO42-, and HCO3- from groundwater samples are plotted on a ternary
diagram to determine the type of water based on the hydrochemical content. The results of plotting the
percentages of the three elements Cl-, SO42-, and HCO3- for water sources include mature, peripheral,

11
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

and steam-heated water (Figure 6b). The fluids in locations C1, C2, C3, C4, C5, and C6 have a peripheral
water type. While the fluid contained in hot springs H1, H2, H3, and H4 near Mt Wayang and Mt Windu
are generally of the type of steam hot water, this indicates that the water is formed on the lower slopes
of the geothermal system.

4.5. Direct utilization for medical geology treatment and balneotherapy


Through field investigations, primary hydrochemical analysis, and secondary data analysis, it becomes
feasible to ascertain the precise whereabouts of water sources that hold potential for application in
medical geology and balneotherapy. According to [46], for springs to be suitable for balneological
purposes, they must possess minerals that are appropriate for balneotherapy, have the potential for
sustainable discharge, and demonstrate a high degree of mineralization while simultaneously having a
low presence of undesirable contaminants. It is imperative to consider the diversity of significant aspects
and the continuity of the flow rate [15].
The hydrochemical composition of hot and cold springs exhibits variations, influencing their
utilization. The hot springs that meet the standards for good health and balneotherapy requirements are
at designated areas H1, H2, H3, and H4. Based on the available data, it can be observed that the hot
springs located in various regions of Pangalengan exhibit suitability for engaging in bathing and body
contact activities. However, it is essential to note that these hot springs are unacceptable for drinking
water. The cold springs in C1, C2, C3, C4, C5, and C6 satisfy the established criteria for drinking water.
The mineral composition of cold springs in volcanic regions renders them appropriate for utilization as
a viable supply of pristine water. Direct utilization is contingent upon several balneological features
specific to each potential site, as each site necessitates distinct criteria for balneotherapeutic investment.

5. Conclusion
Hydrochemical analysis and field verification enable the identification of water sources that exhibit
promising potential for applications in medical geology and balneotherapy. The hot and cold springs'
hydrochemical composition shows variations, rendering them suitable for diverse applications. Hot
springs that possess favorable health characteristics following the standards of balneotherapy can be
identified at designated sites H1, H2, H3, and H4. The hydrochemical analysis reveals that the hot
springs in various regions of Pangalengan exhibit favourable characteristics for bathing and bodily
contact activities. However, it is essential to note that these hot springs are deemed unsuitable to
consume as drinking water. Cold springs located in C1, C2, C3, C4, C5, and C6 have characteristics that
align with the requirements for potable water. Further investigation is necessary to mitigate the adverse
effects of hazardous toxic components through the implementation of direct utilization strategies, which
a comprehensive analysis should inform of various hydrochemical characteristics. This discovery is
relevant and warrants further exploration, serving as a crucial link between science and society.

Acknowledgements
The authors would like to extend their gratitude to Dr. Iwan Setiawan S.T., M.T, Head of the Research
Centre for Geological Resources at BRIN, for granting permission to use the laboratory facilities at E-
Science Services at the National Research and Innovation Agencies (BRIN) Laboratory to analyze the
water samples.

Author contributions
R. Maria conducted the calculations discussed, wrote, and revised the manuscript. R Prasetio addressed
the concept of the physical parameters results and guided the manuscript report. H. Nurohman worked
on the spatial analysis. R.M Shoedarto discussed the data and physical parameters. A. Yuliyanti
discussed the data and physical parameters. H. Lestiana discussed the concept idea. E.N. Dida discussed
the laboratory data, and Y. Rahayudin discussed physico-chemical parameters and guided conclusions.

12
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

Each author contributed equally to the planning and writing of the study for this article, and they all read
and approved the final text.

References
[1] Finkelman, R. B., Orem, W. H., Plumlee, G. S., & Selinus, O. (2018). Applications of
Geochemistry to Medical Geology. In Environmental Geochemistry: Site Characterization,
Data Analysis and Case Histories: Second Edition (Issue January).
https://doi.org/10.1016/B978-0-444-63763-5.00018-5
[2] Fendorf, S., Michael, H. A., & Van Geen, A. (2010). Spatial and temporal variations of
groundwater arsenic in South and Southeast Asia. Science, 328(5982), 1123–1127.
https://doi.org/10.1126/science.1172974
[3] Huggins, X., Gleeson, T., Castilla‐Rho, J., Holley, C., Re, V., & Famiglietti, J. S. (2023).
Groundwater connections and sustainability in social‐ecological systems. Groundwater, April.
https://doi.org/10.1111/gwat.13305
[4] Wang, Y., Yuan, S., Shi, J., Ma, T., Xie, X., Deng, Y., Du, Y., Gan, Y., Guo, Z., Dong, Y., Zheng,
C., & Jiang, and G. (2023). Groundwater Quality and Health: Making the Invisible Visible.
Environ. Sci. Technol., 57(13), 5125–5136.
https://doi.org/https://doi.org/10.1021/acs.est.2c08061
[5] World Water Quality Alliance. (2021). Assessing Groundwater Quality: A Global Perspective:
Importance, Methods and Potential Data Sources. A Report by the Friends of Groundwater in
the World Water Quality Alliance, 60. https://groundwater-quality.org/friends-groundwater-
produce-perspective-paper-groundwater-quality
[6] Hasan, S. E. (2021). Medical Geology. January.
[7] Ríos Reyes, C. A., Ríos Gutiéttez, M. P., & Joya Neira, S. (2020). The importance of minerals in
medical geology: Impacts of the environment on health. Archivos de Medicina (Manizales),
21(1), 0–3. https://doi.org/10.30554/archmed.21.1.3589.2021
[8] Torres-Ceron, D. A., Acosta-Medina, C. D., & Restrepo-Parra, E. (2019). Geothermal and
mineralogic analysis of hot springs in the Puracé-La Mina Sector in Cauca, Colombia.
Geofluids, 2019. https://doi.org/10.1155/2019/3191454
[9] Lee, J. M., Koh, D., Chae, G., Kee, W., & Ko, K. (2021). Integrated assessment of major element
geochemistry and geological setting of traditional natural mineral water sources in South
Korea at the national scale. Journal of Hydrology, 598(February), 126249.
https://doi.org/10.1016/j.jhydrol.2021.126249
[10] Centeno, J. A., Finkelman, R. B., & Selinus, O. (2016). Medical geology: Impacts of the natural
environment on public health. Geosciences (Switzerland), 6(1), 6–8.
https://doi.org/10.3390/geosciences6010008
[11] Maria, R., Rusydi, A. F., Iskandarsyah, T. Y. W. M., Suganda, B., & Hendarmawan, H. (2022).
Impact of natural conditions and anthropogenic activities on groundwater quality in Puntang
volcanic area , West Java ,. IOP Conf. Series: Earth and Environmental Science, 1047
(2022(doi:10.1088/1755-1315/1047/1/012037).
[12] Lazzerini, F., & da Silva, P. (2020). Guarani aquifer system (GAS): geothermal spa balneology
assessment. Boletin Sociedad Española Hidrologia Medica, 35(1), 33–59.
https://doi.org/10.23853/bsehm.2020.0965
[13] Erfurt-cooper, P. (2010). The Importance of Natural Geothermal Resources in Tourism. April,
25–29.
[14] Wangchuk, P., Yeshi, K., Ugyen, K., Dorji, J., Wangdi, K., Samten, Tshering, P., & Nugraha, A.
S. (2021). Water-based therapies of bhutan: Current practices and the recorded clinical
evidence of balneotherapy. Water (Switzerland), 13(1). https://doi.org/10.3390/w13010009
[15] Al Dulaymie, A. S., Hussien, B. M., Gharbi, M. A., & Mekhlif, H. N. (2013). Balneological study
based on the hydrogeochemical aspects of the sulfate springs water (Hit-Kubaiysa region),
Iraq. Arabian Journal of Geosciences, 6(3), 801–816. https://doi.org/10.1007/s12517-011-

13
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

0385-5
[16] Buck, B. J., Londono, S. C., McLaurin, B. T., Metcalf, R., Mouri, H., Selinus, O., & Shelembe,
R. (2016). The emerging field of medical geology in brief: Some examples. Environmental
Earth Sciences, 75(6). https://doi.org/10.1007/s12665-016-5362-6
[17] Shoedarto, R. M., Aries, F. R., Irawan, D., Perdana, F., Arisbaya, I., & Indrawan, B. (2016).
Raising Public Acceptance of Geothermal Utilization Through Direct Application in
Indonesia. Workshop on Geothermal Reservoir Engineering, 2007, 9.
[18] Vaidya, B., & Nakarmi, S. (2020). A Qualitative Study of Patients' Beliefs and Perception on
Medicinal Properties of Natural Hot Spring Bath for Musculoskeletal Problems. Journal of
Environmental and Public Health, 2020. https://doi.org/10.1155/2020/3694627
[19] Dam, M. A. C., & Suparan, P. (1992). Geology of the Bandung basin. Geological Research and
Development Centre, Special Publication No 13.
[20] Bemmelen, R. W. Van. (1970). The Geology of Indonesia, Vol. 1A, General Geology of Indonesia
and Adjacent Archipelago. Martinus, Nilhoff, The Haque, New York, 2nd Edition.
[21] Alzwar, M., Akbar, N., & Bachri, S. (1992). Geological Map of the Garut and Pameungpeuk
Quadrangle, Java.
[22] Freeze, R. A., & Cherry, J. A. (1979). Groundwater. Prentice Hall, New Jersey.
[23] Rounds, R. S. A. (2012). 6 . 6 Alkalinity and Acid Neutralizing Capacity. 0, 1–45.
[24] Powell, T., & Cumming, W. (2010). Spreadsheet for Geothermal Water and Gas Geochemistry.
10. https://earthsciences.stanford.edu/ERE/pdf/IGAstandard/SGW/2010/powell.pdf
[25] Olatunde, P. S., Olubunmi, N., Adeleye, A. O., & Oba, I. A. (2020). Seasonal variation on the
Hydrochemistry and Height of Brackish- water from Commodore channel , Lagos , Nigeria.
November. https://doi.org/10.13140/RG.2.2.27289.03681
[26] Wang, Wang, G. L., Gan, H. N., Liu, Z., & Nan, D. W. (2018). Hydrochemical Characteristics
and Evolution of Geothermal Fluids in the Chabu High-Temperature Geothermal System,
Southern Tibet. Geofluids, 2018, 1–15. https://doi.org/10.1155/2018/8532840
[27] WHO. (2011). Water quality for drinking: WHO guidelines. Encyclopedia of Earth Sciences
Series, 876–883. https://doi.org/10.1007/978-1-4020-4410-6_184
[28] Adeola Fashae, O., Abiola Ayorinde, H., Oludapo Olusola, A., & Oluseyi Obateru, R. (2019).
Landuse and surface water quality in an emerging urban city. Applied Water Science, 9(2), 1–
12. https://doi.org/10.1007/s13201-019-0903-2
[29] El Adnani, I., Younsi, A., Namr, K. I., El Achheb, A., & Irzan, E. M. (2020). Assessment of
seasonal and spatial variation of groundwater quality in the coastal sahel of Doukkala,
Morocco. Nature Environment and Pollution Technology, 19(1), 17–28.
[30] Lachassagne, P. (2021). Lachassagne2021_Article_ReviewHydrogeologyOfWeatheredC. 2561–
2594.
[31] Esteller, M. V., Kondratenko, N., Expósito, J. L., Medina, M., & Martin del Campo, M. A. (2017).
Hydrogeochemical characteristics of a volcanic-sedimentary aquifer with special emphasis on
Fe and Mn content: A case study in Mexico. Journal of Geochemical Exploration, 180(October
2016), 113–126. https://doi.org/10.1016/j.gexplo.2017.06.002
[32] Gnanachandrasamy, G., Ramkumar, T., Venkatramanan, S., Vasudevan, S., Chung, S. Y., &
Bagyaraj, M. (2015). Accessing groundwater quality in lower part of Nagapattinam district,
Southern India: using hydrogeochemistry and GIS interpolation techniques. Applied Water
Science, 5(1), 39–55. https://doi.org/10.1007/s13201-014-0172-z
[33] Ahmed, S., Mulhim, M., Qureshi, F., Kohli, S. K., Hussain, A., Muqtada, M., Khan, A., Mansor,
E., & James, E. (2021). Hydrogeochemical characteristics, temporal and spatial variation for
the evaluation of groundwater quality of Ganga alluvial plain for an agricultural region, India.
September. https://doi.org/10.20944/preprints202109.0079.v1
[34] Haddy, F. J., Vanhoutte, P. M., & Feletou, M. (2006). Role of potassium in regulating blood flow
and blood pressure. American Journal of Physiology - Regulatory Integrative and Comparative
Physiology, 290(3), 546–552. https://doi.org/10.1152/ajpregu.00491.2005

14
12th ITB International Geothermal Workshop (IIGW) 2023 IOP Publishing
IOP Conf. Series: Earth and Environmental Science 1293 (2024) 012002 doi:10.1088/1755-1315/1293/1/012002

[35] Hem, J. D. (1985). Study and interpretation of the chemical characteristics of natural water. US
Geological Survey Water-Supply Paper, 2254.
[36] Geiger, H., & Wanner, C. (2012). Magnesium in disease. CKJ: Clinical Kidney Journal,
5(SUPPL. 1). https://doi.org/10.1093/ndtplus/sfr165
[37] Pawar, N. J., & Shaikh, I. J. (1995). Nitrate pollution of ground waters from shallow basaltic
aquifers, Deccan Trap Hydrologic Province, India. Environmental Geology, 25(3), 197–204.
https://doi.org/10.1007/BF00768549
[38] Gaikwad, S., Gaikwad, S., Meshram, D., & Wagh, V. (2020). Geochemical mobility of ions in
groundwater from the tropical western coast of Maharashtra , India : implication to
groundwater quality. In Environment, Development and Sustainability (Vol. 22, Issue 3).
Springer Netherlands. https://doi.org/10.1007/s10668-019-00312-9
[39] Zak, D., Hupfer, M., Cabezas, A., Jurasinski, G., Audet, J., Kleeberg, A., McInnes, R.,
Kristiansen, S. M., Petersen, R. J., Liu, H., & Goldhammer, T. (2021). Sulphate in freshwater
ecosystems: A review of sources, biogeochemical cycles, ecotoxicological effects and
bioremediation. Earth-Science Reviews, 212(November 2020).
https://doi.org/10.1016/j.earscirev.2020.103446
[40] Yuan, R., Zhang, W., Gan, H., Liu, F., Wei, S., & Liu, L. (2022). Hydrochemical Characteristics
and the Genetic Mechanism of Low–Medium Temperature Geothermal Water in the
Northwestern Songliao Basin. Water (Switzerland), 14(14).
https://doi.org/10.3390/w14142235
[41] Skapare, I., Kreslins, A., & Gjunsburgs, B. (2003). Balneological properties of the geothermal
water in Latvia. Proceedings of European Geothermal Conference. http://www.geothermal-
energy.org/pdf/IGAstandard/EGC/szeged/O-6-03.pdf
[42] Gomes, C. de S. F. (2013). Naturotherapies Based on Minerals. Geomaterials, 03(01), 1–14.
https://doi.org/10.4236/gm.2013.31001
[43] Hamidizadeh, Simaeetabar, Farhad, Sara, Moghadam, & Mohammad Gohari, M. M. P. (2017).
Composition of minerals and trace elements at Mamasani thermal source: A possible
preventive treatment for some skin diseases. Journal of Education and Health Promotion,
6(Desember), 1–6. https://doi.org/10.4103/jehp.jehp_100_17
[44] Giggenbach, W. (1988). Geochemical techniques in geothermal exploration,. UNITAR UNDP,
Guidebook: Application of Geochemnistry in Resources Development, hh. 119-144.
[45] Nicholson, K. (1993). Geothermal Fluids Chemistry and Exploration Techniques. Springer-
Verlac Inc. : Berlin.
[46] Gálvez, I., Torres-Piles, S., & Ortega-Rincón, E. (2018). Balneotherapy, immune system, and
stress response: A hormetic strategy? International Journal of Molecular Sciences, 19(6).
https://doi.org/10.3390/ijms19061687

15

You might also like