Professional Documents
Culture Documents
SPECDSr
SPECDSr
SPECDSr
67
Description:
Use:
Energy transport and distribution. Suitable for buried plumbing.
Installation Fall of
Air Installation
Underground Voltage
LVAV Aluminum Cable (3)
(two)
ÿUkm
Intensity [A]
Intensity (1) [A] Cos ÿ=0.8 (4)
LVAV Aluminum Cable
440 311 0.432
1x150mm², 0.6/1.0kV LVAV
Aluminum Cable
590 423 0.296
1x240mm², 0.6/1.0kV
Machine Translated by Google
68
(1) - The current intensities are indicated for a single-core cable without thermal influences
exteriors. In the case of single-pole cable associations, multiply the indicated values by 0.80.
2. XLPE CU Cable
Reference standards:
Main Features:
Main Features:
Insulation: PEX - Cross-linked polyethylene or HEPR - High elastic modulus ethylene propylene rubber
Dimensional Characteristics
69
Electrical Characteristics
Resistance
Electrical resistance Capacity Inductance Reactance Impedance
Copper cable AC power at
DC at 20ÿC W L XL Z90ÿC
90ÿC
[ÿ/km] [ÿF/km] [mH/km] [ÿ/km] [ÿ/km]
[ÿ/km]
Cable
1x95mm², Voltage 3.6/6.0kV a 285 293 271 274 361 369 434
18/30kV
70
It is an aluminum alloy conductor compared to Copper (Cu) with the wide advantages it presents, such as greater resistance
to saline environments; greater lightness; smaller deflection, higher conductivity for the same cross section as copper; similar
mechanical resistance and lower production cost compared to the cost of aluminum conductors with a steel core. The use of
Al alloy as an earth conductor is an alternative solution that aims to mitigate the theft of AL and Copper while respecting the
ratio of the two sections.
Aluminum Alloy – is nothing more or less than a compound/mixture of AL with other metals as shown in the figure below.
For the electricity sector, it uses aluminum alloy made from Aluminum, Magnesium and Silicon . In this context, for the
transport and distribution of electrical energy, cables and conductors are manufactured instead of traditional aluminum cables
with a steel core.
Designation Characteristics
Anti-theft conductor for grounding The aluminum alloy made with a base of
Aluminum, Magnesium and Silicon
The electrical conductivity of the anti-theft conductor must be equivalent to a 35 mm2 copper conductor. The driver’s
characteristics must be very clear, such as:
- Nominal section;
- Electrical conductivity;
- Impedance;
- Mechanical resistance;
71
TECHICAL REQUIREMENTS
Ratings and Basic Requirements
TECHICAL REQUIREMENTS
Ratings and Basic Requirements
TECHICAL REQUIREMENTS
Ratings and Basic Requirements
TECHICAL REQUIREMENTS
Ratings and Basic Requirements
72
TECHICAL REQUIREMENTS
Ratings and Basic Requirements
TECHICAL REQUIREMENTS
Ratings and Basic Requirements
TECHICAL REQUIREMENTS
Ratings and Basic Requirements
TECHICAL REQUIREMENTS
Ratings and Basic Requirements
73
TECHICAL REQUIREMENTS
Ratings and Basic Requirements
3.10. Command and control cable coils 4x6 - 16mm2 VAV (DTNO)
TECHICAL REQUIREMENTS
Ratings and Basic Requirements