Professional Documents
Culture Documents
Hydrated Lime - SDS
Hydrated Lime - SDS
INTRODUCTION DETAILS
PRODUCT DETAILS
COMPANY DETAILS
1 of 7
SECTION 2: HAZARD IDENTIFICATION
2 of 7
Storage/disposal P405 Store locked up
P501 Dispose of contents/container in accordance with
local/regional/national/international regulations.
Inhalation Shift to open area inhales fresh air. If no breathing give artificial
respiration. If breathing is difficult, give oxygen. If symptoms persist get
medical help.
Ingestion If conscious, immediately give 2 to 4 glasses of water or milk and induce
vomiting by putting finger to back of throat. Never give anything by
mouth to an unconscious person. Get immediate medical attention.
Skin contact Wash thoroughly with soap and water. Remove contaminated clothing
and shoes. Seek medical attention. Wash clothing before reuse.
Eye contact Flush with plenty of water at least 30 minutes occasionally lift upper and
below eyelids. Seek immediate medical practitioners help.
3 of 7
extinguishing water must be disposed off in accordance with local
regulations.
Explosion hazards in presence of various chemical No Data Available.
Handling Avoid dust formation and accumulation. Avoid contact with eyes, skin,
and clothing. Avoid breathing vapor.
Storage Store in cool, dry and well-ventilated area. Keep away from acids. Keep
container closed. Protect from physical damage.
c. Ventilation Use adequate general or local exhaust ventilation to keep vapor levels as
low as possible.
4 of 7
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
5 of 7
b. Eyes May cause mild irritation or redness.
Chronic effect At present no chronic toxicity has been observed.
Target Organs Respiratory system, skin and eyes.
Mobility Calcium hydroxide, which is sparingly soluble, and present a low mobility
in moist soils.
Bioaccumulation No Data Available.
Biodegradability No Data Available.
Toxicity LC50 (96h) for freshwater fish: 50.6 mg/L
LC50 (96h) for marine water fish: 457 mg/L
Disposed in accordance with all applicable federal, state and local environmental regulations.
UN Number: 3262
UN proper shipping name: Corrosive solid, Basic, Inorganic, N.O.S
Class: 8
Packing group: III
Malaysia Regulations:
2. OSHA (Use and Standard Exposure of Chemicals Hazardous to Health) Regulations 2000
6 of 7
SECTION 16: OTHER INFORMATION
All statements, information and data presented herein are believed to be accurate and reliable but are
not to be taken as guarantee, express warranty or implied warranty of merchantability of fitness for a
particular purpose or representation express or implied, for which seller assumes legal responsibility and
they are offered solely for your consideration, investigation and verification. Statements or suggestions
concerning possible use of this product are made without representation or warranty that any such use
is free of patent infringement and are not recommendations to infringe on any patent.
Take notes that all chemicals have hidden hazards end should be used with extreme care. The various
hazards listed hereinbefore are in no way exhaustive.
7 of 7