Professional Documents
Culture Documents
Copy-SS I TECHNICAL DRAWING
Copy-SS I TECHNICAL DRAWING
PAPER 1
(OBJECTIVE) Section A
D. 75°
6. In the figure above, the line X-X divides the 14. In a scale drawing, if the scale is 1:50,
circle into what does a measurement of 50mm in the
A. semi-circle. drawing represent in real life?
B. sector. A. 250 cm
C. segment. B. 1 cm
D. quadrant C. 2500 cm
D. 10 cm
7. The angle which we can't make using a
single Set-square is ________ 15. Which type of triangle has all its sides of
different lengths?
A. 45°
B. 60° A. Equilateral triangle
C. 30° B. Isosceles triangle
C. Scalene triangle
1
D. Right triangle II.points of tangency
16. What is the interior angle sum of a
pentagon?
A. 360 degrees
B. 540 degrees
C. 720 degrees
D. 900 degrees
17. In a triangle, what is the name of the side
opposite the right angle?
A. Hypotenuse 4. Construct a regular pentagon with side
B. Adjacent side length of 60mm in ratio of 5:3.
C. Opposite side
D. Base 5. In one drawing using general method,
construct a 5, 7 and 9 sided polygon of length
18. When enlarging a shape with a scale 40mm.
factor of 3, what happens to its area
compared to the original shape?
A. It remains the same
B. It becomes 3 times smaller
C. It becomes 3 times larger
D. It becomes 9 times larger
19. How many degrees are in the exterior
angle of a regular hexagon?
A. 60 degrees
B. 120 degrees
C. 150 degrees
D. 180 degrees
20. In a scale drawing, if the distance between
two points is 6 cm on the drawing with a scale
of 1:20, what is the actual distance between
the points?
A. 120 cm
B. 100 cm
C. 30 cm
D. 12 cm
SECTION B
Answer all
1. List 4 properties of a polygon. [ 4 marks ]
SECTION C
Answer question 1 and any other two
1. A Square with length 50 is reduced to
ratio 7:4.
State with construction, the size length of the
reduced circle.