Professional Documents
Culture Documents
The Boho Bag Saver
The Boho Bag Saver
Supplies Needed:
-5 mm size H hook
-Regular sized hair elastic (preferably a new one), the thicker kind. You don’t want it to be
stretched out.
-150-175 yards of DK weight (size 3) or worsted weight (size 4) yarn (I used Lion Brand Comfy
Cotton Blend)
-15-20 mm wooden bead (optional)
-4"piece of cardboard (optional)
-Scissors, tape measure, yarn needle
Beginning - beg
Chain(s) - ch(s)
Double Crochet - dc
Fasten Off - FO
Half Double Crochet - hdc
Single Crochet - sc
Skip - sk
Slip Stitch - sl st
Space(es) - sp(s)
Stitch(es) - st(s)
Treble Crochet - Tr
V-Stitch - Vst
1|Page
Special Stitches:
V-Stitch- Make {1 Tr, ch 5, 1 Tr} into indicated st.
Gauge:
Gauge is not essential for this project, but I do give my diameter measurement after round 2 to
give you a baseline measurement.
Finished Measurements:
Finished bag saver will measure approximately 4.5" (11.5 cm) wide x 24" (61 cm) long.
Instructions:
Begin by making a sl st into the hair elastic.
Round 1: Ch 1, 40 hdc inside hair elastic. Join with a sl st in top of first hdc. [40 hdc] NOTE:
Your hdc should be completely covering the hair elastic but should not be ruffling up. See photo.
Round 2: Ch 2 (beg ch 2 does not count as a st from here on out), dc in same st as join and in
next 2 sts, 2 dc in next st, * dc in next 3 sts, 2 dc in next st; rep from * to end. Join with a sl st in
first dc. [50 dc]
Gauge check
The diameter of my base is approximately 4" (10 cm). If yours does not measure the same,
adjust hook size accordingly and start over.
Rounds 3-4: Ch 2, dc in each st to end. Join with a sl st in first dc. [50 dc]
2|Page
Round 7: Ch 9 (counts as 1 Tr + ch 5), Tr in same st (Vst made), ch 3, sc in ch sp of next Vst,
ch 3, * Vst in next sc, ch 3, sc in ch sp of next Vst, ch 3; rep from * to end. Join with a sl st in 4th
ch of beg ch 9, sl st in next 2 chs of beg ch 9. [5 Vsts, 5 sc, 10 ch 3-sps] (see photo below)
Round 25: Ch 1, * sc in next sc, 2 sc in next ch sp, sc in next Tr, 3 sc in ch-5 sp, sc in next Tr, 2
sc in next ch sp; rep from * to end. Join with a sl st in first sc. [50 sc]
Rounds 26-27: Ch 1, hdc in each st to end. Join with a sl st in first hdc. [50 hdc]
Round 28: Ch 1, hdc in each st to end, ch 12, sl st in top of last hdc made to create a loop. Join
with a sl st in first hdc. [50 hdc, 1 ch-12 sp]
Round 29: Ch 1, sc in each st until ch-12 sp, 12 sc in ch sp. Join with a sl st in first sc. FO,
leaving a long 6”-8” tail. [62 sc]
Take long tail and wrap around the base of the ch 12 loop to further secure. Weave in tail and
cut off excess. Weave in beginning tail.
3|Page
Pictured are worsted weight versions in Hobby Lobby’s ILTY in the colors Sleight Gray and Black. They
turned out to be the exact same size for me as the DK weight version, but I did intentionally crochet a bit
tighter since I knew the yarn was technically bulkier.
4|Page