Professional Documents
Culture Documents
12 Series-33
12 Series-33
12 Series-33
MAINTENANCE
for scratches, scuffing, etc. Figure 6-12 Blowdown Valve (P/N 044912)
2. Disassemble the o-ring from the piston.
3. Discard the old o-ring. Replace the o-ring with the
new one provided in the kit.
4. Remove and replace the valve body quad-ring and
reassemble the cylinder to the valve body.
PRESSURE REGULATING VALVE MAINTE-
NANCE
Refer to Figure 6-11. Pressure control regulator (P/N
406929) maintenance normally requires the replace-
ment of the internal diaphragm. Use repair kit No.
041742 and follow the procedure below for proper in-
stallation
1. Loosen the locknut and turn the adjusting screw
counterclockwise until the inner spring tension is
relieved. The adjusting screw should turn freely
when the spring tension is relieved.
2. Remove the spring chamber from the body to al-
low access to the internal parts.
3. Next, remove the spring button and the spring.
The dampener will stay inside the spring as it is re-
moved. Leave the dampener inside the spring as
there is no need to remove it.
4. After removing the spring, remove the gasket stop
and brass gasket.
5. At this time, remove the pressure plate nut and
disassemble the pressure plat, diaphragm, dia-
phragm gasket seat disc and seat gasket.
6. Remove and discard the seat ring.
7. The next step is to reassemble the regulator using
27