Professional Documents
Culture Documents
Exercise 8-1
Exercise 8-1
Exercise 8-1
Creating Floors
Exercise 8-1
1. Start Revit 2018
7. Using context tab, using Draw panel, select Pick Supports and pick all the
outer beams of the building (make sure the first pick is on horizontal beam).
Press [Esc] twice to get out from the picking process. Using Modify panel
select Offset command, make sure Numerical is selected, set Offset = 650 and
turn off Copy. Hover over one of the lines, then press [Tab] key, to highlight all
boundary lines, then click when you see the dashed line outside the current
line
11. Select the floor you just copied, and click Edit Boundary button. Delete the line
representing the arc. Link the horizontal lines with vertical lines to form a
closed boundary. Click ( ) to end the command
15. Select the floor and click Edit Boundary. Using Pick Lines, set offset = 650, and
click gridline G
16. Using Trim/Extend to Corner, trim the boundary to be closed and continuous,
also, delete the old vertical line. Click ( ) to end the command
8-12
Chapter 8: Creating Floors
17. Go to 06 Roof floor plan view, and repeat the steps above but with gridline H
22. Start Ref Plane command, select Pick Lines tool, and set Offset = 2000mm
23. Pick A to the inside, and then pick B to the inside. Do the same thing with 2 & 3
8-13
Revit Structure 2018 Essentials
28. Set Top Constraint = 06 Roof, Top Offset = 362mm (to go flush with the floor
thickness)
31. Using two opposite corners of the four reference planes draw the walls of the
elevator
34. From Draw panel, select Pick Lines tool, set offset = 500mm
35. Pick the four outside edges of the wall, and click ( ) to end the command
36. Start Shaft command, pick rectangle tool, and draw the shaft inside the four
walls. Set Base Constraint = T.O.F, Base Offset = 0
37. Set Top Constraints = 06 Roof, and Top Offset = 370mm (or any value greater
than 362 – i.e. the thickness of the floor). Don’t forget to draw an (X) to indicate
elevator void
8-14