Professional Documents
Culture Documents
Polymer Insulators
Polymer Insulators
Polymer Insulators
Overhead distribution line construction - bare
or covered conductors
––
Spacer Cable
––
Tree wire
Available for 1" or 1-3/8" pin construction
These insulators are manufactured from a
proprietary high-density polyethylene-based
compound having a dielectric constant that is
similar to (and compatible with) polyethylene
covered overhead conductor.
Features
Tie top designs are perfect for use with
all PLP ties
Matched dielectric properties with Jacketed
Conductor
Superior moisture and contamination shedding
UV stabilized material
High impact resistance
Lightweight design
Head dimensions - ANSI 29.5 & 29.6 compliant
Dramatically reduces abrasion
Ideal for jumpers and stinger wires
100% Recyclable
Spool Insulator
www.preformed.com
Polymer Insulators Tie Top – Pin-Type
PLP Catalog Mounting Pin
Description
Number ANSI Class* Application
Neutral Applications
IP-53-2** 53-2 A-Neck - 1-3/4" Diameter 5/8"
15kV Applications
IP-15-C** 55-3 C Neck 1"
25kV Applications
IP-25-F1 55-5 1"
F Neck
IP-25-F2 55-5† 1-3/8"
IP-25-J1 56-1† 1”
J Neck
IP-25-J2** 56-1 1-3/8"
35kV Applications
IP-35-F1 55-6† 1"
F Neck
IP-35-F2 55-7† 1-3/8"
IP-35-J1 55-6 1"
J Neck
IP-35-J2 55-7 1-3/8"
* Nominal ANSI C29.5 or C29.6 Class designation
** RUS Accepted
† Meets the electrical requirements of the ANSI Class designation, but there are differences in the
physical characteristics.
INSULATOR PIN
NYLON HEAD, M16 STUD
366±10 mm
216±2 mm
M16x2
PLP’s forged steel insulator pins are designed to be used in PLP insulator pins have a nylon thread over-moulded onto the
conjunction with medium voltage distribution pin insulators. steel forging which screws into the pin insulator. Insulator pins
The pin is designed so that a spanner can be applied to the are supplied in accordance with ANSI Standard C135.17,
bottom of the shank with a wide base to distribute load stresses. galvanised and with hardware that includes spring washer and
nut as shown.
PLP insulator pins can be used with steel or wooden crossarms
and are attached to the crossarm by an M16 stud. The length
of the stud can be customised to suit any utility crossarm
dimensions, with standard stud lengths being listed in the
table below.
www.preformed.com
PLP Distribution Products
INSULATORS
TENSION INSULATOR
SILICONE RUBBER, 70kN
PLP’s silicone rubber longrod insulators are designed for tension PLP longrod insulators are type tested in accordance with
or suspension applications in utility distribution networks. Suitable the requirements of IEC 61109:2008. The insulator has a
for both bare wire and covered conductor applications, the minimum failing load of 70kN and features clevis and tongue
insulator weather sheds are manufactured from hydrophobic end fittings that are hot dip galvanised and designed to work
silicone rubber. seamlessly with PLP clevis thimbles.