Professional Documents
Culture Documents
JP150
JP150
JP150
Design Primarily Stourflex JP150 Expansion Joint All JP150 Expansion Joint Guides are available with the
Guides are designed to be utilised in following finishes:
conjunction with Stourflex expansion joints, Friction
Maximum
however they may also be used along the rest Range Finishes Operating
Coefficient
Temperature
of the pipe run. This is because a pipeline Polyamide, glass
suspended on hangers, drop rods or gripple is Standard 0.18µ 110°C
fibre reinforced
free to swing and cannot be considered guided. As Per Standard
ULTRAGlide With Additional 0.07µ 110°C
A further benefit of utilising JP150 Expansion Nano Coating
Joint Guides over the whole run is significantly High
Silicone Lining 0.18µ 250°C
reduced anchor forces (when compared to Temperature
External High Corrosion
traditional supports) due to the low friction Location Protection Plating
0.18µ 110°C
coefficient of the slide.
Complete range of pipe clamps is available to suit ABS, PVC, CPVC, Copper,
Stainless Steel and Carbon Steel Pipework
Stourflex expansion joint guides should be installed in accordance with our fitting
instructions.
04/21
STOURFLEX® Is The Trading Name of J&P Supplies Ltd. Junction Road, Audnam, Stourbridge. DY8 4YH
Tel: 01384 393329 Fax: 01384 440212 E-Mail: info@stourflex.co.uk Web: www.stourflex.co.uk
STOURFLEX
J&P Supplies Ltd
Junction Road, Audnam,
Stourbridge, West Midlands,
DY8 4YH
Tel: 01384 393329
Fax: 01384 440212
Technically Advanced Flexible Solutions www.stourflex.co.uk
Maximum - When threaded rod is used the rod length should not exceed 55mm to ensure its maximum performance and to
Rod Length prevent bending moments being applied.
108mm & - Guides over 108mm should either use a direct connection or use the supplied locknut to lock off the ½” BSP thread
Above on the slide element
Guiding - Stourflex JP150 Expansion Joint Guides should not be used as part of a long drop from the slab or channel (see
Advice maximum rod length above), frames should be utilised to reduce the rod length and not long pieces of rod between
the slide and the clips, the long thread introduces bending moments into the installation which may cause the slide to
lock up instead of sliding smoothly. These frames can be supplied by Stourflex, please contact us for further
information.
Best - When being used in tall risers with larger axial expansion joints at higher pressures, we recommend the use of 6
Practice Guides per expansion joint spaced at 4, 8 and 14 pipe diameters instead of the typical 4 guides spaced at 4 and 14
pipe diameters. This helps prevent squirming in the bellows caused by the use of high pressures axial bellows.
- To achieve the lowest possible anchor forces in an axial expansion joint installation, JP150 expansion joint guides
should be used to support the whole pipe run taking advantage of their very low friction coefficient.
STOURFLEX® Is The Trading Name of J&P Supplies Ltd. Junction Road, Audnam, Stourbridge. DY8 4YH
04/21
Tel: 01384 393329 Fax: 01384 440212 E-Mail: info@stourflex.co.uk Web: www.stourflex.co.uk