Professional Documents
Culture Documents
Brushoff 20L 165X160 Booklet 140X140
Brushoff 20L 165X160 Booklet 140X140
Brushoff 20L 165X160 Booklet 140X140
HARMFUL | ECOTOXIC
KEEP OUT OF REACH OF CHILDREN
BrushOff
C
M ®
CM
MY
CY
CMY
HERBICIDE
K
20 Litres
BRUSHOFF 20L BOOKLET 140X140.pdf 1 8/6/21 5:27 PM
for further information about the use of product that is older than this.
PERSONAL PROTECTION: Avoid contact with eyes and skin. Avoid inhalation of vapour or spray mist. When mixing or applying, wear
overalls, chemical resistant boots and gloves and eye protection. Clean protective clothing daily after work. Do not eat, drink or
smoke while using. Remove protective clothing and wash hands and face thoroughly before meals and after work.
C
USE: Apply with well maintained and calibrated spray equipment.
M
Do not use container for any other purpose.
Y ENVIRONMENTAL: Use this product carefully. Do not contaminate aquatic environments with product, spray drift or empty container. Spray
drift or equipment contamination may cause serious damage to desirable plants. Do not allow spray drift outside the target area to occur.
CM
First Aid WARRANTY
MY If swallowed do not induce vomiting. If splashed in eyes, wash out
immediately with running water for several minutes. If skin or hair ingredient within accepted analytical tolerance when packed. The
CY contact occurs, remove contaminated clothing and wash with soap user bears the risk for damage resulting from factors beyond the
and running water. If inhaled, immediately move to fresh air and manufacturer’s control. The manufacturer declines all liability for
CMY damage resulting from improper storage or use of the product.
National Poisons Centre 0800 POISON (0800 764 766) (24 hrs)
K
or a doctor immediately for advice. Registered pursuant to the ACVM Act 1997, No. P5661
Emergency Response See www.foodsafety.govt.nz for registration conditions.
In a transport emergency call 111, Police or Fire Brigade. For Approved pursuant to the HSNO Act 1996, No. HSR000829
specialist advice in an emergency only, call 0800 CHEMCALL See www.epa.govt.nz for approval conditions.
(0800 243 6225) (24 hrs).
Spillage ®
BRUSH OFF is a Registered Trade Mark of Orion AgriScience Ltd
Exclude non-essential people from the area. Wear protective ™
SYNERGY AND SILMAXX are Trade Marks of Orion AgriScience Ltd
clothing and prevent material from entering waterways. Absorb
spill with inert material such as soil, sand, etc, and place in a Registrant: Agsin Pte Ltd, Zagro Global Hub, 5 Woodlands Terrace,
waste container. Wash area with water, and absorb with further Singapore 738430
Registrant: Orion AgriScience Ltd, Unit 1, 15 Sir Gil Simpson Drive,
Safety Data Sheet Harewood, Christchurch 8053 www.orionagriscience.co.nz
Additional information is provided in the safety data sheet.
Freephone 0800 ORIONAS (0800 674 6627) or visit
www.orionagriscience.co.nz. 0621
CM
during use.
Knapsack: Add 6mls Brush Off per litre of water. Add Synergy™ Penetrant or Silmaxx™ at 10ml per
MY
10 litres water.
MIXING
CY
remainder of water.
CMY COMPATIBILITY
Brush Off may be tank mixed with most commonly used herbicides. Do not use acidic spray marker
K dyes with Brush Off.
RESISTANCE MANAGEMENT
GROUP O3 HERBICIDE
Brush Off contains the active ingredient triclopyr, which belongs to the pyridine carboxylic acid chemical
family. Some naturally occurring weeds may become resistant when excessive use of the same herbicide
occurs. To prevent or delay the development of resistance, use in tank mixes and/or rotate use with
herbicides with a different mode of action. Consult http://resistance.nzpps.org/index.php for alternative
modes of action and details of resistance management strategies (if any) for the uses listed on the label.
BRUSHOFF 5L
BRUSHOFF 20L BOOKLET 140X140.pdf 3 8/6/21 5:27 PM
C Blackberry 300 - 600ml 10 Apply during summer and early autumn when plants are actively growing.
Remove the canes the following spring by burning, crushing or slashing.
M Follow up treatment may be required for regrowth.
Note: Some species of blackberry in Northland and the East Coast of the North Island are not well controlled.
Y The use of a suitable organosilicone penetrant such as Silmaxx or Synergy Penetrant is recommended at 50ml/100 litres.
Use the higher rates for control of hard grazed and lower growing types.
CM
Lupin 150ml 3 Apply during active growth from spring until late summer. The use of a suitable organosilicone penetrant such as Silmaxx or Synergy
MY Penetrant is recommended at 30ml/100 litres.
CY
Sweet Briar 500ml
recommended at 30ml/100 litres.
CMY
Old Mans 400ml Apply November to February before leaf senescence.
K
Beard
Fennel 300ml Apply to actively growing plants (November to February).
Tree tutu 300ml 8 Apply to fresh regrowth after frond expansion. Follow up treatment of regrowth may be required. The use of a suitable organosilicone
penetrant such as Silmaxx or Synergy Penetrant is recommended at 50ml/100 litres.
Note: Apply when the plants are actively growing.
TURFGRASS: For control of creeping oxalis, hydrocotyl and some other broadleaf weeds in turf, use 2