Weekly Plan for Fifth Year (Mechanical) Semester I Examples and Date Lessons Exercises Chapter-1 Introduction 1.1 Open Cycle single shaft and twin shaft arrangement 1st Week 1.2 Multi-spool arrangement 1.3 Closed Cycles 1.4 Aircraft Propulsion 1.5 Industrial Application 2nd Week 1.6 Marine and Land transportation 1.7 Environmental issues 1.8 Some future possibilities Tutorial I 3rd Week 1.9 Gas Turbine design procedure Chapter-2 Shaft Power Cycle 4th Week 2.1 Ideal Cycles 2.1 Ideal Cycles Revision 5th Week Practical I 2.2 Method of accounting for component losses 2.3 Design Point performance Calculations Stagnation Properties Example 6th Week Compressor and turbine efficiency (2.1,2.2,2.3) Pressure Losses Heat exchanger effectiveness 2.4 Comparative Performance of Practical Cycles Mechanical losses Problem (2.1,2.9) 7th Week Variation of specific heat Fuel/air ratio, Combustion and Cycle efficiency 2.5 Combined Cycle and Cogeneration Schemes Practical II 8th Week 2.6 Closed-cycle Gas Turbines Tutorial II Chapter-3, Gas Turbine cycles for aircraft propulsion 9th Week 3.1 Criteria of Performance Example (3.1) 3.2 Intake and propelling nozzle efficiencies 3.3 Simple Turbojet cycle Problem 10th Week (3.1,3.2,3.3) 3.4 The turbofan engine 11th Week 3.5 The turboprop engine Example (3.2), 3.6 The turboshaft engine 3.7 Auxiliary Power Units 12th Week Problem (3.4,3.5) 3.8 Thrust augmentation Chapter-4, Centrifugal Compressor Example (4.1) 13th Week 4.1 Principle of Operation Problem( 4.1) 4.2 Work done and Pressure rise 4.3 The Diffuser Problem 14th Week 4.4 Compressibility Effects (4.2,4.3,4.5) 4.5 Non-dimensional quantities for plotting compressor 15th Week Tutorial III characteristics