Professional Documents
Culture Documents
DGA-Lung Center
DGA-Lung Center
DGA-Lung Center
ELECTRICAL S Y S T E M S
29 Kabignayan Str e et, Tatalon 111 3 , Quezon C ity, Ph ilippines
Te ls + 63 (2) 8743-1906 • 8781 -0011 Fax : +63 (2 ) 8732-1915
36.0
Dl524
D6181
D971
5) Neutralization Number mgKOH/g 0.00825 D974
6) Dielectric strength, 2.5mm gap kV 47.71 D877
7) Water content DPm 32 D1533B
8) Oil power factor (a), 60Hz, 25°C % 0.001 D924
9) Dielectric constant 2.178 D924
10) Resistivity TQ-m 23.9 D1169
pS/m Calculated
11) Conductivity
12) Oil power factor (a), 60Hz, 100°C
13) Oxidation inhibitor content
%
%
--- 0.042
-
----
----- --
~ D924
D2668
14) Dissolved Decay Products Abs/nm ----
--- --- D6802
15) Specific !mlvitv
----- -- D1298
16) Viscosity, 40°C
17) Viscosity, 100°C
cSt
cSt ---- - -- D445
D445
18) Oxidation stability, 72 hours
• Total acid number mgKOH/g ----
--- -- D2440
• Sludge content, by mass %
-- ---
-
19) Corrosive sulfur
20) Flash point oc ------ ---
D1275B
D92
----- -------
21) Pour point oc ~ D97
~
Georgetown Electrical Systems 29 Kabignayan Street, Tatalon, Quezon City 111 3, Philippines Tel: 743-1 906, 781-0011 Fax: 732-1915
Sample ID 20-0655
t otes Analysis Date 06105120
,g~r~~~~r
P!asti c bottl e
!Lab Notes Silicone
Al! detection limits aie less than 1ppm . Note: interpretations and diagnostics developed using mineral oil.
~No Prior Sample Found for this Sample. Therefore cannot perform Guideline.
Note: Our test results relate only to the sample tested. W e do not imply that the contents of the sample received by this lab are the same as all such material in the envi ronme nt
from w hich the sample was taken. The analysis. opinions. or interoretations conta ined in this report are based upon material and information supplied by th e client
< GE S).
LaboratorvJ Results GEORGE:TOWN
ELECTRICAL SY STEMS
Georgetown Electrical Systems 29 Kabignayan Street, Tatalon , Quezon City 11 13, Philippines Tel: 743-1906, 781-0011 Fax: 732-1915
All detection limits aie less than 1ppm . Note: Interpretations and diagnostics developed using mineral oi!.
Dissolved Gas Results - ASTM D 3612
Sampling date 00100100
*Hydrogen H2 12 ppm
* Methane CH4 86
* Ethane C2H6 46 * Combustible gases
* Ethylene C2H4 6
* Acetylene C2H2 0
* Carbon Monoxide CO 1550
Carbon Dioxide C02 12945
Nitrogen N2 168327 Est. TCG (%) 0.63
Oxygen 02 28188 Estimated Total Combustible Gas (TCG) if transformer has a
Total Diss. Comb. Gas TDCG 1700 gas space over the oil. This value is calculated from the solubility
Total Gas Content 211160 factors of the gases involved
Interpretive or Key Gas Method (present sample only) indicates:
Hydrogen v.:ithin normal limits (<1500ppm)
l\ll- Methane >80ppm . Possible local overheating .
..,. Ethane >35ppm. Possible local overheating, possible low energy spark.
Ethylene within normal limits (<150ppm)
Acetylene within normal limits (<?ppm) ·
.... carbon Monoxide >1000ppm. Possible thermal decomposition of cellulose.
F- Carbon Dioxide >1 OOOOppm. Possibie thermal decomposition of celluiose.
Rogers' Ratios (present sample only) indicates:
CH4/H2 = 7.30 Code= 2
C2H6/CH4 = 0.54 Code = 0
C2H4/C2H6 = 0.13 Code= O ..,. Slight overheating < 150C.
C2H2/C2H4 = 0.00 Code= 0
CO/C02 = 0.12 ..,.CO/C02>0.1 Higher than normal temperature in solid insulation.
IEEE/ANSI C57.104 Guideline (Requires TDCG Level from Previous Sample) suggests:
TDCG Levei: 1700 ppm Rate: ----- ppm/day
.... sampling Interval:
..,. Operating Interval:
..,. No Prior Sample Found for this Sampie. Therefore cannot perform Guideline.
Note: Our test results re late only to the sample tested. We do not imply that the contents of the sample received by this lab are the same as all such material in the environment
from which the sample was taken. The analysis. opinions, or interpretations contained in this report are based upon material and information suoplied by the client.
GEORGETOWN
ELECTRICAL S Y S T E M S
29 Kab ignayan Street, Tatalon l l l 3 , Quezon C ity, Ph il ippines
Tels +63 (2) 8743-1906 • 8781 -0011 Fax : +63 (2 ) 8732-1915
- --
---
2) Visual Examination Clear & bright D1524
3) Turbidity
4) Interfacial Tension
NTU
dynes/cm
- 35.9
D6181
D971
5) Neutralization Number mg;KOH/g 0.00544 D974
6) Dielectric strength, 2.5mm gap kV 52.20 D877
7) Water content ppm 34 Dl533B
8) Oil power factor (a), 60Hz, 25°C % 0.001 D924
9) Dielectric constant 2.710 D924
10) Resistivity Tn-m 18.8 Dl169
11) Conductivity
12) Oil power factor (a), 60Hz, 100°C
pS/m
% -----
-
0.054
----- Calculated
0924
13) Oxidation inhibitor content
14) Dissolved Decay Products
%
Abs/run ---
---- --
---
D2668
D6802
15) Specific irravity - D1298
16) Viscosity, 40°C cSt --- -- D445
17) Viscosity, 100°C cSt
-- --- D445
18) Oxidation stability, 72 hours
• Total acid number mgKOH/g ----- --- D2440
• Sludge content, by mass
19) Corrosive sulfur
%
--- ---
--- D1275B
oc --
20) Flash point
21) Pour point oc
-------
--- -------- D92
D97
-----
22) 2-Furfuraldehyde in oil D5837
--
µ_g/l
23) Est. Ave. Degree of Polymerization DP '
/ Chendong
Richard L. Sy J-~