Professional Documents
Culture Documents
Carenado RTU Manual
Carenado RTU Manual
Bright knob
IDENT
Push to ident ATC
COM/NAV Frequency
Push the Standby (right side) COM/NAV LSK to position the tune window around the Standby COM/NAV
frequency.
Set the desired frequency with the tuning knobs. The outer knob controls the hundreds, tens and ones and
the inner knob controls the decimals.
To swap the frequency to the active side, just click again the LSK adjacent to the STDBY side.
ADF Frequency
Push the ADF LSK to position the tune window on the ADF section, the outer knob will highlight the number
to be changed with the inner knob.
ATC code
Push the ATC LSK to position the tune window on the ATC section, the outer knob will highlight the number
Carenado Copyrights all rights reserved
to be changed with the inner knob. To cycle trought transpoder mode, keep pressing the LSK, it will change
from OFF, STBY, ON and ALT ON.
NEXT Page
- To access this display, push the NEXT PAGE LSK at the bottom left of the Main Display
- Frequency selection and subdisplay will use the same procedure as in main display
- RETURN LSK will give you to the Main Display.
HSI Page
- To access this display, push the HSI LSK at the bottom right side of the NEXT PAGE screen
- Frequency , ATC and CRS selection will use the same procedure as in main display
- RETURN LSK will give you to the Main Display.