Professional Documents
Culture Documents
Sam Epoxy Primer ZP - EC
Sam Epoxy Primer ZP - EC
Sam Epoxy Primer ZP - EC
Product description.
A two-component, high solid, polyamide-cured epoxy Primer with excellent anticorrosive
properties due to pigmentation by Zinc phosphate pigments.
Characteristics
• Good abrasion and impact resistance.
• Designed to be used in industrial and marine environment.
• Can be used with water jetting surface preparation.
• Designed to be used as a holding primer that can be recoated after a period of time.
• Compatible with well-designed cathodic protection system.
Physical properties.
Colour Red brown, (specific colours)
Texture Egg Shell
Mixing and application Information
Number of components Two
Mixing ratio By Volume, base to hardener: 80 / 20
Specific gravity Approx. 1.45 g/ml
Volume solids 65±2% Tested acc. ASTM D 2369
VOC Approx. 300 g/liter
Flashpoint >25°C
spray Airless spray Recommended
Pressure at nozzle: 180 - 250 bar. Nozzle size: 0.38 - 0.53 mm..
Spray angle: 40 - 80 degrees.
Thinning Ratio: 0 - 5%.
Convention Air spray
Thinning Ratio: 0 - 10%.
1|Page
January 10, 2022 (Revision of January 10, 2020)
Technical data sheet
The drying and curing periods are established by subjecting the product to controlled temperatures and
a relative humidity level that does not exceed 85%, and at average DFT range for the product.
2|Page
January 10, 2022 (Revision of January 10, 2020)
Technical data sheet
Disclaimer
All information in this document has been prepared to the best of SAMCO's knowledge, based on laboratory
testing and practical experience to ensure good workmanship. However, the responsibility for executing the work
stays with the applicator/ contractor/sub-contractor. SAMCO products are used under conditions beyond SAMCO's
control. Users should always consult SAMCO for specific guidance on the general suitability of this product for
their needs and specific application practices. SAMCO reserves the right to change the given data without further
notice.
3|Page
January 10, 2022 (Revision of January 10, 2020)