Connec ons SITUATION 1. The figure shows an Eccentrically SITUATION 2. The figure shows an Eccentrically Loaded Bracket. Loaded Bracket. M20, Fnv = 457 MPa. Throat thickness is 8 mm, E70xx.
Take Fw = 0.6FEXX
Determine the following: Determine the following:
a. Design shear strength of the bolt (KN) a. Force per mm at the most cri cal weld if b. Allowable shear strength of the bolt (KN) P is 100KN. (manual) If theta is 20 degrees, PDL = 10KN, PLL = 8KN, using b. Force per mm at the most cri cal weld if LRFD, determine the following: P is 100KN. (kaltek) c. Weld stress at the most cri cal weld if P c. Force at the most cri cal bolt. is 1KN. =))) d. Force at the least cri cal bolt. d. Ul mate load P that the assembly can e. Maximum addi onal live load the carry if DL = 50KN. assembly can carry due to shear strength e. Allowable load P that the assembly can of the bolt. carry if LL = 50KN. If theta on figure is 30 degrees, PDL = 10KN, PLL = 8KN, using ASD and kaltek (show syntax on calculator as your solu on), determine the following:
f. Force at the most cri cal bolt.
g. Force at the least cri cal bolt. h. Maximum addi onal live load the assembly can carry due to shear strength of the bolt.