Professional Documents
Culture Documents
HTC 34063A DC-DC Converter
HTC 34063A DC-DC Converter
FEATURES
Operation from -0.3V to 40V Input
Low Standby Current
Current Limiting
Output Switch Current to 1.5A
Output Voltage Adjustable
Frequency Operation to 42kHz
Precision 2% Reference
APPLICATION
DC-DC Converter
ORDERING INFORMATION
Orderable
Temperature Range Package Package Qty
Device
SOP8L MC34063ADG 75Units/Tube
0°C to +70°C SOP8L Pb-Free MC34063ADRG 2500Units/Tape
DIP8L MC34063APG 50Units/Tube
1
MC34063A DC-TO-DC Converter Control Circuits
SCHEMATIC DIAGRAM
8 1
Drive Switch
Collector Collector
S Q Q2
R Q1
7 100
Ipk 2
Sense
Switch
Emitter
Ipk
Oscillator GT
6 3
VCC Timing
Capacitor
+
1,25V
Comparator Reference
_ Regulator
5 4
Comparator GND
Inverting
Input
(Bottom View)
Figure 1. Representative Schematic Diagram
2
MC34063A DC-TO-DC Converter Control Circuits
ELECTRICAL CHARACTERISTICS
(Vcc = 5.0V, TA=0 to +70°C, unless otherwise specified)
Parameter Symbol Test Conditions Min Typ Max Unit
OSCILLATOR
Frequency fosc V Pin5 =0V,C T =1.0nF,T A = 25°C 24 33 42 kHz
Charge Current Ichg V CC = 5.0V to 40V, T A = 25°C 24 33 42 μA
Discharge Current I dischg V CC = 5.0V to 40V, T A = 25°C 140 200 260 μA
Discharge to Charge
Idischg/Ichg Pin7 to V CC , T A =25°C 5.2 6.2 7.5
Current Ratio
Current Limit Vlpk(sense) I chg = I dischg , T A = 25°C 250 300 350 mV
Sense Voltage
OUTPUT SWITCH (Note 3)
Saturation Voltage, I SW = 1.0A,
VCE(sat) 1.0 1.3 V
Darlington Connection Pins 1, 8 connected
ISW = 1.0A, Forced β = 20
Saturation Voltage, VCE(sat) 0.45 0.7 V
Darlinton Connection RPin 8 = 82Ω to VCC
I SW = 1.0A, V CE =5.0V,
DC Current Gain hFE 50 75
T A = 25°C
Collector Off-State
IC(off) V CE = 40V 40 100 μA
Current
COMPARATOR
T A = 25°C 1.225 1.25 1.275
Threshold Voltage V th V
T A = T low to T high 1.21 1.29
Threshold Voltage
Reg line V CC = 3.0V to 40V 1.4 5.0 mV
Line Regulation
Input Bias Current IIB V in = 0V -20 -400 nA
TOTAL DEVICE
V CC = 5.0V to 40V,
Supply Current ICC C T = 10nF, V pin7 = V CC , 2.5 4.0 mA
V Pin5 > V th , Pin 2 = GND,
Remaining pins open
NOTE 2: Low duty cycle pulse techniques are used during test to maintain juction temperature as
close to ambient temperature as possible
3
MC34063A DC-TO-DC Converter Control Circuits
Assembly Information:
4
MC34063A DC-TO-DC Converter Control Circuits
TYPICAL PERFORMANCE CHARACTERISTICS
ton-off.OUTPUT SWITCH ON-OFF TIME(μS)
1000
VOSC,OSOCILLATOR VOLTAGE(V)
500 V CC =5.0V
200 Pin7=V CC
Pin5=GND
100 T A =25°C
200 mV / DIV
50
t on
20
10
5.0
t off VCC=5.0V Pins1,5,8=Open
2.0 Pin7=VCC CT=1.0μF
1.0 Pin2=GND TA=25°C
0.01 0.02 0.05 0.1 0.2 0.5 1.0 2.0 5.0 10 10μS / DIV
CT,OSCILLATOR TIMING CAPACITOR(nF)
Figure 2. Output Switch On−Off Time vs. Figure 3. Timing Capacitor Waveform
Oscillator Timing Capacitor
1.8
VCE(sat),SATURATION VOTAGE(V) 1.1
1.0
VCE(sat),SATURATION VOTAGE(V)
1.7
0.9
Darlington Connection
1.6 0.8
0.7
1.5
0.6 VCC=5.0V
1.4 0.5 Pin7=Vcc
VCC=5.0V Pins 2,3,5=GND
Pins1,7,8=Vcc 0.4 TA = 25ºC
1.3 Pins3,5=GND Forcedβ = 20
TA = 25ºC 0.3
1.2
0.2
1.1 0.1
0
1.0
0 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 0 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6
Figure 4. Emitter Follower Configuration Output Figure 5. Common Emitter Configuration Output Switch
Saturation Voltage vs. Emitter Current Saturation Voltage vs. Collector Current
3.6
400
380 3.2
VIPK(sense),CURRENT LIMIT
ICC,SUPPLY CURRENT(mA)
Vcc=5.0V
360 Ichg=Idischg 2.8
340 2.4
SENSE VOLTAGE(V)
320 2.0
300
1.6
280
1.2 CT=1.0nF
260
0.8 Pin7=Vcc
240 Pin2=GND
220 0.4
200 0
-55 -25 0 25 50 75 100 125 0 5.0 10 15 20 25 30 35 40
5
MC34063A DC-TO-DC Converter Control Circuits
TYPICAL APPLICATION
L1
170μH
R3 8 1
DRC SWC
180Ω
7 2
Ipk SWE D1
BYV10-40
RSG 6 3
VCC TC
0.22Ω
VIN 5 4
CII GND VOUT
12V
+
C2 C3
100μF 1.5nF
R1 R2
2.2kΩ 47kΩ
+
C3
330μF
For VOUT=28V
Parameter Test Conditions Result(Typ) Unit
Line Regulation VIN = 8 to 16 V, IO = 175 mA 30 mV
Load Regulation VIN = 12 V, IO = 75 to 175 mA 10 mV
Output Ripple VIN = 12 V, IO = 175 mA 300 mV
Efficiency VIN = 12 V, IO = 175 mA 89 %
6
MC34063A DC-TO-DC Converter Control Circuits
TYPICAL APPLICATION(CONTINUED)
8 1
DRC SWC
BYV10-40
7 2
Ipk SWE
RSC
0.33Ω D1
6 3
VCC TC
5 4
Vin CII GND L1
220μH
+
C2 C3
100μF 470pF
R2 R1
1.2kΩ 3.6kΩ
+
C1
470μF
For VOUT = 5V
Parameter Test Conditions Result(Typ) Unit
Line Regulation VIN = 15 to 25 V, IO = 500 mA 5 mV
Load Regulation VIN = 25 V, IO = 50 to 500mA 30 mV
Output Ripple VIN = 25 V, IO = 500 mA 100 mV
Efficiency VIN = 25 V, IO = 500mA 80 %
ISC VIN = 25 V, Rload = 0.1 Ω 1.2 A
7
MC34063A DC-TO-DC Converter Control Circuits
TYPICAL APPLICATION(CONTINUED)
8 1
DRC SWC
L1
7 2
Ipk SWE
RSC 90μH
0.22Ω
6 3
VCC TC
VIN 5 4
4.5 to 6V CII GND
D1
+ BYV10-40
C2 C3
100μF 1.5nF
R2 R1
VOUT
-12V / 100mA
8.2kΩ 953kΩ
C1
1000μF
+
8
MC34063A DC-TO-DC Converter Control Circuits
TYPICAL APPLICATION(CONTINUED)
1 VOUT
S Q Q2
+
R Q1
7
Ipk
RSC
Oscillator
3
VIN 6 1.25V
+ Reference
Comparator Regulator
4
_
1
S Q Q2
R Q1
7
Ipk
RSC
Oscillator
3
VOUT
VIN 6 1.25V
+ Reference +
Regulator
Comparator 4
_
9
MC34063A DC-TO-DC Converter Control Circuits
TYPICAL APPLICATION(CONTINUED)
1
S Q Q2
R Q1
VOUT
2
+
7
RSC Ipk
Oscillator 3
VIN 6 1.25V
+ Reference
Regulator
Comparator 4
_
1
S Q Q2
R Q1
RSC Ipk
Oscillator 3
VOUT
VIN 6 1.25V
+ Reference
Regulator
Comparator 4 +
_
10
MC34063A DC-TO-DC Converter Control Circuits
TYPICAL APPLICATION(CONTINUED)
1
S Q Q2
R Q1 VOUT
2 +
7
Ipk
RSC Oscillator 3
VIN
6 1.25V
+ Reference
Comparator Regulator
4
_
+12V
GND
+
8
1
Q2 -12V
S Q
R Q1
RSC Ipk
Oscillator 3
VIN 6 1.25V
+ Reference
Comparator Regulator
4
_
11
MC34063A DC-TO-DC Converter Control Circuits
TYPICAL APPLICATION(CONTINUED)
+ +VOUT
-VOUT
+
8
1
S Q Q2
R Q1
VIN 7
RSC Ipk 3
Oscillator
6 1.25V
+ Reference
Comparator Regulator
4
_
12
MC34063A DC-TO-DC Converter Control Circuits
CALCULATION
Table 1 Design Formula Table
ton (ton + toff) - toff (ton + toff) - toff (ton + toff) - toff
CT 4.0×10 -5 ton 4.0×10 -5 ton 4.0×10 -5 ton
ton ton
Ipk(switch) (
2Iout(max) toff + 1 ) 2Iout(max) (
2Iout(max) toff + 1 )
0.3 0.3 0.3
RSC I PK(switch) IPK(switch) IPK(switch)
(Vin(min) - Vsat) (Vin(min) - Vsat - Vout) (Vin(min) - Vsat)
L(min) ton(max) ton(max) ton(max)
Ipk(switch) Ipk(switch) Ipk(switch)
Ioutton Ipk(switch)(ton + toff) Ioutton
CO ≈ ≈
Vripple(p-p) 8Vripple(p-p) Vripple(p-p)
13
MC34063A DC-TO-DC Converter Control Circuits
PHYSICAL DIMENSIONS
SOP8L
A3 A1 A2
4
B1
R2
3
A
R1
B2
C1
C
C2
C4
C3
D1
Dimension(mm) Dimension(mm)
Symbol Symbol
Min Max Min Max
A 4.95 5.15 C3 0.05 0.20
A1 0.37 0.47 C4 0.20(TYP)
A2 1.27(TYP) D 1.05(TYP)
A3 0.41(TYP) D1 0.40 0.60
B 5.80 6.20 R1 0.07(TYP)
B1 3.80 4.00 R2 0.07(TYP)
B2 5.0(TYP) 1 17 (TYP)
C 1.30 1.50 2 13 (TYP)
C1 0.55 0.65 3 4 (TYP)
C2 0.55 0.65 4 12 (TYP)
14
MC34063A DC-TO-DC Converter Control Circuits
DIP8L
A D2
1
2
B
D1
D
C4
C1
C
C2
C3
A5
A3 A4
A1
A2
Dimension(mm) Dimension(mm)
Symbol Symbol
Min Max Min Max
A 9.30 9.50 C2 0.5(TYP)
A1 1.524(TYP) C3 3.3(TYP)
A2 0.39 0.53 C4 1.57(TYP)
A3 2.54(TYP) D 8.20 8.80
A4 0.66(TYP) D1 0.20 0.35
A5 0.99(TYP) D2 7.62 7.87
15