Download as pdf or txt
Download as pdf or txt
You are on page 1of 14

MasterEmaco®SBR 2

High dispersion SBR Latex ensuring higher mixing efficiency with water reduction for site batched
mortars & waterproofing/bonding slurry/screed

DESCRIPTION • Corrosion control:Prevents corrosion of


embedded steel.
MasterEmaco SBR 2 is a milky-white, Styrene- • High Dispersion technology:Allows for better
Butadiene co-polymer latex liquid, produced from workability at slightly reduced water
styrene and butadiene by high pressure emulsion
polymerization with high dispersive PROPERTIES
properties.When used with cement, concrete and Aspect Milky-white, Styrene-
plaster, it reduces the mixing time through high
Butadiene co-polymer latex
dispersion of the polymer and improves
waterproofing, new to old concrete/plaster bonding pH 8±1
and strength characteristics and reduces Relative density 1.02± 0.01 at 25oC
shrinkage and cracking of the mix. Solid content 37±1%

RECOMMENDED USES Properties of Polymer modified mortar


Mortar proportioning
Concrete repair: Spalled concrete, repairing Cement 50 Kg
floors, beams and pre-cast slabs, chajjas etc. Quartz Sand (Zone II) 150 Kg
• Bond Coat: For bonding new concrete to old MasterEmaco SBR 2 10 Litre
concrete, plaster, stone/brick masonry. Water 10 Litre
• Plaster repair: For repairing plaster or making Fresh wet density 2000 – 2200kg/m3
water proof plaster which is better than normal Mortar Compressive 40MPa at 28days
plaster. strength* (ASTM C
• Floor screeds and toppings: Abrasion 109), 70*70*70
resistant and non-dusting floors. Mortar Flexural 10MPa
• Waterproofing:Basements side walls and strength* (ASTM C
rafts, lift pits, inspection pits, sunken/overhead 348)
water tank,sunken portions of bathrooms and Mortar Tensile 5MPa
toilets, balconies, chajjas, exposed roofs strength*
before finished screed. (BS 6319,pt.7)
• Other typical applications: Bedding tiles, Adhesion for Bond >1.5MPa or concrete
fixing or re-fixing slip bricks. Coat failure.
(ASTM D 4541)
FEATURES AND BENEFITS Water permeability for Nil at 5 Bar
waterproof coat
• Multiple applications: Robust product that is (DIN 1048)
economical, easy to handle and store. *Properties are of typical mix and guiding in nature, and may
• Easy to Mix: Faster mixing to enhance worker vary depending upon mix constituents. BASF strongly
efficiency. advises to carry out site mix design and site trials.
• Shrinkage/crack control:High flexural /
tensile strength to control cracking.
• Mortar modifier- Improved flexibility, no APPLICATION
bleeding, lower water cement ratio and high
resistance to water penetration. Surface preparation
• Improves physical/mechanical properties – • Remove all loose concrete, grease, mould
higher abrasion resistance, good adhesion to oil or curing compound from concrete and
building materials similar thermal steel surfaces using wire brush, scrubber.
characteristics to concrete.
MasterEmaco®SBR 2
• Saw cut the concrete areas to a square or • Mix required quantity ofMasterEmaco
rectangular profile to a minimum 10mm SBR 2and waterfor 2 minutes in a
depth at the extreme edges. separate container, to avoid excessive air
• Roughen the surface free of loose entrapment.
particles and dust and saturate with water. • Finally, without delay, add the liquid mix
• Remove excess/standing water. slowly into the mixer containing the mixed
powdered sand/coarse aggregate and
Bonding slurry cement until the required consistency is
• Mix 1½ parts cement to 1 part achieved.
MasterEmaco SBR 2 by weight of
cement. Rendering to vertical surfaces
• Mix to a lump-free creamy, consistency for • Apply the bonding slurry to the prepared
2-3minutes by slowly adding surface and then apply the MasterEmaco
MasterEmaco SBR 2. SBR 2rendor onto the wet bonding slurry.
• Using a stiff brush, work the bonding slurry • Application Thickness: 5 to 25mm.
well into the damp surface. When the bond • Greater thickness can lead to slumping.
coat is tacky apply mortar/screed overlay. • Apply multiple layers in rapid succession,
within 15 to 30 minutes of the previous
As waterproofing slurry: layer.
• Mix 2 parts cement to 1 part • Finish the surface using a wooden float or
MasterEmaco SBR 2 by weight of steel trowel.
cement. • Apply modified slurry coat on the first layer
• Mix to a lump-free creamy, consistency for in case application of second layer is
2-3 minutes by slowly adding delayed to long time gaps.
MasterEmaco SBR 2.
• Using a stiff brush, work first coat of Screeds and toppings, applied to horizontal
waterproofing slurry well into the damp surfaces
surface. • Application thickness 10mm to 40mm.
• After the first coat has dried, apply second • The MasterEmaco SBR 2 modified mix
coat at right angle to first followed by should be placed over the still wet bonding
mortar/screed overlay. Average time gap slurry, well compacted by hand and
between two coats is 3 to 4 hours. trowelled to finish using a wooden float or
steel trowel.
Mix Design: Mortar&Screed. Curing:Moisture cure for 24 hours and then allow
• Mix Design Repair Mortar: 10 Litre of to dry slowly
MasterEmaco SBR 2:50kg of
Cement:150kg of sieved sand:10litres of ESTIMATING DATA
water.
• Mix Design Floor Topping/Screed. 10 Usage Mixing Ratio Consistency
Litre of MasterEmaco SBR 2: 50Kg of Bond Coat 1(polymer) :1.5(cement) Slurry
Cement: 75Kg of sand: 75kg of coarse Waterproofing 1(polymer) :2(cement) Slurry
aggregate (6mm down): 10litres of water. slurry Coat

Mixing Process Mortar/Screed:


Repair mortar 1(polymer):5(cement): Thixotropic
• Use fresh, lump free cement, well graded 15(sand):1 (water)
sand/aggregates free of excessive fines.
• Mix sand and cement and coarse Floor Screeds 1(polymer):5(cement) Thixotropic
/ PCC :7.5(sand):7.5 coarser
aggregate in Pan Type mixer for 1 -2 Topping aggregate:1 (water)
minutes. Hand mixing is only permissible
when the total weight of the mix is less
than 25kg.
Mixing ratios
MasterEmaco®SBR 2
Coverage PRECAUTIONS
Bonding Coat: 4 to 4.5m2 for mix of 1 Litre
MasterEmaco SBR 2 and 1.5kg of cement. For the full health and safety hazard information
and how to safely handle and use this product,
Waterproofing slurry:2 m2 in two coats for mix of please make sure that you obtain a copy of the
1LitreMasterEmaco SBR 2 and 2kg of cement. BASF Material Safety Data Sheet (MSDS) from
our office or our website.
Repair Mortar/Concrete Screed: 10 Litre of
MasterEmaco SBR 2 per 50kg of cement. MasterEmaco SBR 2 /01/0615

PACKAGING
MasterEmaco SBR 2 is supplied in 1, 5, 20 Litre.

SHELF LIFE

Store under cover, out of direct sunlight and


protect from extremes of temperature. In tropical
climates the product must be stored in an air-
conditioned environment.
Shelf life is 12 months when stored as above.

The technical information and application advice given in this BASF Construction Chemicals publication are based
STATEMENT OF on the present state of our best scientific and practical knowledge. As the information herein is of a general nature,
RESPONSIBILITY no assumption can be made as to a product's suitability for a particular use or application and no warranty as to its
(Disclaimer) accuracy, reliability or completeness either expressed or implied is given other than those required by law. The
user is responsible for checking the suitability of products for their intended use.
® = registered trademark of BASF group in many countries
Field service where provided does not constitute supervisory responsibility. Suggestions made by BASF
NOTE Construction Chemicals either orally or in writing may be followed, modified or rejected by the owner, engineer or
contractor since they, and not BASF Construction Chemicals, are responsible for carrying out procedures
appropriate to a specific application.

BASF India Limited


Construction Chemicals Division
Plot.No.12,TTC Area
Thane BelapurRoad,Turbhe
Navi Mumbai - 400705,India
Tel: +91 22 67127600, Fax: +91 22 67917358
E-mail: construction-india@basf.com , www.master-builders-solutions.basf.in
MasterKure® 181
Acrylic resin based, multi-role curing, sealing and protective membrane

DESCRIPTION Drying time (ASTM : 45 mins at 25oC


MasterKure 181 is a non-degrading, membrane- C309)
forming liquid based on specially formulated acrylic
resin suitable for curing newly placed or freshly TEST CERTIFICATION/APPROVALS
deshuttered concrete; assists in the retention of  Clear version - ASTM C309 Type I Class B
water during hydration. The resultant film retains  White version - ASTM C309 Type II Class B
sufficient moisture in the concrete to ensure full
hydration of the cement; essential for optimum COVERAGE
strength development. The cured concrete is The recommended rate of application is 4-6
typically harder and exhibits a dust free surface square metres per litre. This corresponds to that
with a reduced incidence of drying shrinkage at which MasterKure 181 has been tested, and at
cracks. Additionally, the membrane acts as a which it attains the claimed degree of curing
primer system for many subsequent surface efficiency. In favourable conditions such as shaded
finishes that do not rely on penetration for interior surfaces, adequate curing can be achieved
substrate bond. When applied to floors, the with extended coverage rates.
MasterKure 181seals and dustproof the surface, When using MasterKure 181 for floor areas where
eliminating the primary source of abrasion and maximum chemical and wear resistance is
enhancing durability. required, it is recommended that a further coat be
MasterKure 181 is available as a clear translucent applied after 24 hours.
liquid and white solar reflective version. In place of the above recommendations, the rates
RECOMMENDED USES of cover stipulated in a specification should at all
times be observed.
As a more effective and economical alternative to
separate curing and priming/sealing APPLICATION
regimes.Suitable for use on all concrete surfaces. Surface Preparation
 Surfaces subject to finishing treatments.
 Economical enhancement of concrete flatwork.
 In high-rise construction to eliminate the NEWLY PLACED CONCRETE:
requirement for water. Surface must be sound and properly finished.
FEATURES AND BENEFITS Surface is ready for application of MasterKure
181, when damp, but not wet, and it can no longer
 Improves moisture retention in concrete be marred by foot traffic.
 Prevents rapid water evaporation
 Sealer & dustproofer
 Good abrasion resistance – long protection NEWLY CURED BARE CONCRETE:
 Reduces drying shrinkage Level any gouges. Remove all dirt, dust, oil,
 Reduces the incidence of hairline cracks grease, asphalt, and foreign matter. Clean with
 High curing efficiency caustics and detergents as required. Citrus
 Available in Solar reflective grade degreaser is excellent for removing oil stains and
 Non – degrading – no removal required many curing compounds. Rinse thoroughly and
 Act as primer for protective coatings & bitumen allow to dry. Apply MasterKure181 to damp but
not wet surfaces.
PERFORMANCE TEST DATA
AGED CONCRETE:
Restore surface to soundness by patching,
Appearance : Clear/white liquid grouting, and filling cracks or holes. Surface must
Specific gravity : 0.82 ± 0.01 at 25º C also be free of any dust, dirt, and other foreign
Clear matter. Use power tools or strippers to remove any
incompatible sealers or coatings. Clean as
White : 0.855 ±0.01 at 25º C
required, following procedure under “Newly cured
Flash point : 65° C bared concrete”.
Dry film appearance :Clear or white Application
Loss of Water (ASTM : < 0.55 kg /m2
C156)

Page 1 of 2
MasterKure® 181
Stir MasterKure 181thoroughly before using. comply with ASTM C 309 Class B. The product
Apply a continuous, uniform film by low-pressure shall exhibit water loss not more then 0.55 kg/m2 in
spray, short nap roller or brush. 72 hours when tested as per ASTM C156. The
Application not recommended when surface product shall form non-degrading abrasion
temperature exceeds 40oC resistance film which shall also exhibit capability
as primer for subsequent protective coatings or
Subsequent surface finishes
bituminous overlays.
The resin in MasterKure 181 ensures that bond is
maintained with adhesives used for installing tiles, PACKAGING
and other floor coverings. MasterKure 181 will act MasterKure 181 is available in 5 & 20 litre packs.
as a primer for paint systems and will enable most
surface treatments to progress with minimal delay.
STORAGE /SHELF LIFE
Typical surface treatments that will bond to
surfaces with MasterKure 181 are: MasterKure 181 must be stored where
temperatures do not drop below +5°C. Store under
 Water based emulsion paints containing PVA,
cover, out of direct sunlight and protect from
PVC and acrylic co-polymers
extremes of temperature.
 Tile adhesives based on the above polymers
 Bituminous emulsions and solutions. Shelf life is12 months when stored as above.
 Thin section polymer modified cementitious Failure to comply with the recommended storage
systems. conditions may result in premature deterioration of
 Polyurethane resin system the product or packaging. For specific storage
 Polysulphide systems advice consult your local Master Builders Solutions
 Epoxy resin compositions which do not rely on representative.
penetration for substrate bond. PRECAUTIONS
For further information regarding compatibility of As with all chemical products, care should be
MasterKure 181, contact your local Master taken during use and storage to avoid contact with
Builders Solutions Representative. eyes, mouth, skin and foodstuffs (which can also
be tainted with vapour until product fully cured or
Cleaning dried). Treat splashes to eyes and skin
immediately. If accidentally ingested, seek
Use CLEANING SOLVENT NO. 2 to clean rollers
immediate medical attention. Keep away from
and spray equipment before MasterKure 181
children and animals. Reseal containers after use.
become dry. Any excess cured material will have
Do not reuse containers for storage of consumable
to be mechanically removed.
item. For further information refer to the material
SUGGESTED SPECIFICATION safety data sheet.
The non-degrading membrane forming curing &
sealing compound shall be MasterKure 181, TDS Ref. no.: Masterkrxx181/02/08/2021
acrylic resin based formulation. The product shall

® = registered trademark of a MBCC Group member in many countries of the world

The technical information and application advice given in this Master Builders Solutions publication are based on the
STATEMENT OF present state of our best scientific and practical knowledge. As the information herein is of a general nature, no
RESPONSIBILITY assumption can be made as to a product's suitability for a particular use or application and no warranty as to its
(Disclaimer) accuracy, reliability or completeness either expressed or implied is given other than those required by law. The user
is responsible for checking the suitability of products for their intended use.

Field service where provided does not constitute supervisory responsibility. Suggestions made by Master Builders
NOTE Solutions either orally or in writing may be followed, modified or rejected by the owner, engineer or contractor since
they, and not Master Builders Solutions, are responsible for carrying out procedures appropriate to a specific
application.

Master Builders Solutions India Private Limited


Registered office: Plot No D-126,
TTC Industrial Area, MIDC,
Shiravane, Navi Mumbai - 400706,
Maharashtra, India
Tel: +91 8657906776
E-mail: Construction-india@mbcc-group.com
www.master-builders-solutions.com/en-in
MasterEmaco® S 488 (formerly known as Emaco S88C T)

Dual shrinkage compensated, trowelable fibre reinforced thixotropic repair mortar

DESCRIPTION Substrate +5 to +40°C


material +5 to +30°C
MasterEmaco S 488 trowelable mortar is a dual
shrinkage compensated, thixotropic high strength Mixing water per 25kg bag Approx. 3.25 – 3.75
formulation for structural concrete repairs. litres
MasterEmaco S 488 is suitable for placing in Compressive strength 20 MPa 1 Day
thicknesses of 12mm to 50 mm both vertically and (ASTM C109 7cm cube)
50 MPa 3 Days
overhead.
60 MPa 7 Days
MasterEmaco S 488 provides a durable, strong
structural repair fully compatible with host 70 MPa 28 Days
concrete. Flexural Strength >9 MPa @ 28 days
RECOMMENDED USES (ASTM C348)
MasterEmaco S488 is the ideal material for Tensile Strength >4 MPa @ 28 days
vertical or horizontal structural repairs where the (ASTM C496)
thickness of repair is more than 12mm and use of
Resistivity approx. 12500Ωcm
hand or machine applied structural repair systems
is required. Typical applications are: Water penetration < 5mm
 Extensive repairs to beams, columns and other Coefficient of Oxygen 2.58 x 10-8
structural elements. diffusion
 Repair of structural members subjected to
repetitive loading. APPLICATION
 Repairs to piers, navigation locks, dams Surface preparation
seawalls and other marine structures All loose traces of concrete or mortar, dust, grease
 Repairs to bridges, tunnels, garages, silos etc oil, etc. must be removed. Damaged or
FEATURES AND BENEFITS contaminated concrete shall be removed to obtain
a keyed aggregate exposed surface. Non-impact/
 Dual shrinkage compensated - Volume stable vibrating cleaning methods, e.g. grit or high
in wet and hardened state reducing cracking pressure water blasting are recommended. Cut the
tendency edges of the repair vertically to a minimum depth
 One component, factory made only addition of 5 mm. Clean all exposed reinforcement to a
of water - Uniform predictable performance minimum grade of Sa 2 according to ISO 8501-1 /
even in remote situations ISO 2944-4. Ensure back of reinforcing bar is also
 No bonding agent required - Simple clean.
installation
Where reinforcing bars are corroded, cut back the
 Impermeable to aggressive elements - Long concrete to at least 20mm behind the reinforcing
life repairs bars. Grit blast around the reinforcing bars to
 Sprayable - Able to repair complex profiles remove corrosion products and coat with
easily with minimal rebound MasterEmaco P 130 to give corrosion protection..
 Fast and easy placing - Reduced time for Replace the affected part of rebar if the diameter
repairs after grit blasting is found reduced by more than
20% of the original diameter on the advice of the
PROPERTIES
structural engineer responsible for the works.
Appearance Grey powder Mixing
Water powder ratio 0.14 Only full bags are mixed. Damaged or opened
bags should not be used. Mix MasterEmaco S
Density Approx. 2300 kg/m3 488 in a forced action pan mixer, or with a helical
Application temperature paddle attached to a low speed (300-600rpm)
mixer for 3 minutes until a lump free, thixotropic
MasterEmaco® S 488 (formerly known as Emaco S88C T)
consistency is achieved. Only use clean water. thicker layers in smaller patches or where
Mixing water needed: 3.25 to 3.75 litres per 25kg additional reinforcement is present. Smoothing
bag. Allow the mortar to rest for 2 - 3 minutes and with a trowel or finishing by float or sponge can be
then remix briefly before applying. If the done as soon as the mortar has begun to stiffen.
temperature is more than 300C then use chilled Protective coatings
water for the mixing water.
Subsequent coatings of MasterProtect anti-
Priming Concrete carbonation barriers or silane impregnations
No special primer is required. To obtain extra should be applied as recommend on the individual
strong bonding, the damp substrate can be primed datasheets.
with a slurry brush coat of MasterEmaco S 488 (2 CURING
parts powder to 1 part water).
MasterEmaco S 488 should be cured with
Mortar application
MasterKure 181 or clear polythene sheeting over
The minimum temperatures must be maintained wet hessian.
during application and for at least 24 hours
thereafter for optimum curing of the product. ESTIMATING DATA
The prepared substrate should be pre-soaked, Each bag of MasterEmaco S 488 when mixed
preferably for 24 hours, but at least 2 hours before with 3.5L of water yields 12.4L.
applying MasterEmaco S 488 The surface must PACKAGING
be saturated surface dry, but without standing
water. MasterEmaco S 488 can be spray or hand MasterEmaco S 488 is available in 25kg bags.
applied. Apply mixed product directly to the SHELF LIFE
prepared damp substrate, or wet in wet onto the MasterEmaco S 488 has a shelf life of 6 months.
primed surface. Spraying the material with the Store out of direct sunlight, clear of the ground on
necessary pressure will ensure good adhesion of pallets protected from rainfall.
the material.
PRECAUTIONS
A thin scrape coat or contact layer before building
up to the required thickness, wet on wet, will For the full health and safety hazard information
improve adhesion especially in case of hand and how to safely handle and use this product,
application. Apply to the desired layer thickness of please make sure that you obtain a copy of the
12 mm to max 50 mm and level using a screeding BASF Material Safety Data Sheet (MSDS) from
bar, trowel or wooden board. Can be applied in our office or our website.

MasterEmacoS488/01/0313

The technical information and application advice given in this BASF Construction Chemicals publication are based
STATEMENT OF on the present state of our best scientific and practical knowledge. As the information herein is of a general
RESPONSIBILITY nature, no assumption can be made as to a product's suitability for a particular use or application and no warranty
as to its accuracy, reliability or completeness either expressed or implied is given other than those required by law.
(Disclaimer) The user is responsible for checking the suitability of products for their intended use.

Field service where provided does not constitute supervisory responsibility. Suggestions made by BASF
NOTE Construction Chemicals either orally or in writing may be followed, modified or rejected by the owner, engineer or
contractor since they, and not BASF Construction Chemicals, are responsible for carrying out procedures
appropriate to a specific application.

BASF India Limited


Construction Chemicals Division
Plot No.37, Chandivali Farm Road, Chandivali, Andheri(East)
Mumbai – 400072 India
Tel: +91 22 28580200, Fax: +91 22 28478381
e-mail: construction-india@basf.com www.basf-cc.co.in
MasterEmaco® S 466
High Strength dual shrinkage compensated, flowable micro concrete for concrete repairs

DESCRIPTION Mixing water per 25kg bag Approx. 3.75-4.25 litres


MasterEmaco S 466 micro concrete pourable Temperature for application Between +5 and +40°C
mortar is a dual shrinkage compensated, high flow, (substrate and material) (+5 and +30°C)
high strength formulation for structural concrete
Flexural Strength >8 MPa
repairs.
(ASTM C 348)
MasterEmaco S 466 is suitable for placing in
thicknesses of 25mm to 200 mm. Resistivity appox. 12500Ωcm
MasterEmaco S 466 provides a durable, strong Water penetration < 5mm
structural repair fully compatible with host concrete.
APPLICATION
RECOMMENDED USES
Surface preparation
MasterEmaco S 466 is the ideal material for
vertical or horizontal structural repairs where the All loose traces of concrete or mortar, dust, grease
thickness of repair is more than 25mm and use of oil, etc. must be removed. Damaged or
pourable mortar is preferable to hand or machine contaminated concrete shall be removed to obtain
applied repair systems. Typical applications are: a keyed aggregate exposed surface. Non-impact/
vibrating cleaning methods, e.g. grit or high-
 Extensive repairs to beams, columns and other pressure water blasting are recommended. Cut the
structural elements edges of the repair vertically to a minimum depth of
 Repairs to piers, navigation locks, dams 20 mm. Clean all exposed reinforcement to a
seawalls and other marine structures minimum grade of Sa 2 according to ISO 8501-1 /
 Repair of structural members subjected to ISO 2944-4. Ensure back of reinforcing bar is also
repetitive loading clean
 Repairs to bridges, tunnels, garages, silos etc Where reinforcing bars are corroded, cut back the
 Jacketing of beams, columns and other concrete to at least 20mm behind the reinforcing
structural elements for strengthening bars Water powder ratio and coat the old and new
FEATURES AND BENEFITS reinforcement with MasterEmaco P 130 for
superior protection from corrosion.
 Dual shrinkage compensated - Volume stable
in wet and hardened state reducing cracking Grit blast around the reinforcing bars to remove
tendency corrosion products. Replace the affected part of
 One component, factory made only addition reinforcing bar if the diameter after grit blasting is
of water- Uniform predictable performance even found reduced by more than 20% of the original
in remote situations diameter on the advice of the structural engineer
 No bonding agent required - Simple responsible for the works.
installation
 Impermeable to aggressive element: long life Formwork
repairs
The forms must be of good quality, treated with a
 Pourable mortar- Able to repair complex
chemical release agent such as MasterFinish for
profiles easily
smooth release, provided with water drain holes,
 Fast and easy placing-Reduced time for repairs strong and well braced to withstand the fluid
PROPERTIES pressure of the mortar until it hardens.
Mixing
Appearance Grey powder Only full bags are mixed. Damaged or opened bags
Water powder ratio 0.16 should not be used. Mix MasterEmaco S 466 in a
forced action pan mixer, or with a helical paddle
Compressive strength 20 MPa 1 Day
(ASTM C109 7cm cube)
attached to a low speed (300-600rpm) mixer for 3
35 MPa 3 Days minutes until a lump free, flowable consistency is
50 MPa 7 Days achieved. Only use clean water.
65 MPa 28 Days
Mixing water needed: 3.75 to 4.25 litres per 25kg
bag. Allow the mortar to rest for 2 - 3 minutes and
Density 2.25 ± 0.1 g/cc then remix briefly before pouring into formwork. If

Page 1 of 2
MasterEmaco® S 466
the temperature is more than 40 0C. Better use CURING
chilled water for mixing.
MasterEmaco S 466 should be cured after
Mortar application formwork removal by MasterKure 181 or with wet
The minimum temperatures must be maintained hessian cloth.
during application and for at least 24 hours
ESTIMATING DATA
thereafter for optimum curing of the product. The
prepared substrate should be pre-soaked, Each bag of MasterEmaco S 466 when mixed with
preferably for 24 hours, but at least 2 hours before 4L of water yields 13.2L. This is near approximate
applying MasterEmaco S 466 ensure all water is value and user is requested to establish trials at site.
removed from formwork prior to installation and PACKAGING
formwork is resealed. MasterEmaco S 466 should
be pumped or poured into the prepared formwork MasterEmaco S 466 is available in 25kg bags.
until the void is filled. Pumping is recommended for SHELF LIFE
larger pours. Do not vibrate MasterEmaco S 466 MasterEmaco S 466 has a shelf life of 6 months.
as it could lead to segregation. Store out of direct sunlight, clear of the ground on
The formwork should be removed after 1-3 days pallets protected from rainfall.
and a curing compound applied. If subsequent
PRECAUTIONS
coats are to be applied the use of clear polyethene
recommended for the first three days after removal It is highly recommended to use necessary PPE
of formwork. For repairs beyond 80mm to 100mm (Gloves, mask etc.,) during installation of the
in thickness, extend MasterEmaco S 466 with up product. In case of Incidents of direct inhalation,
to 25kg of 5-12mm sized washed, saturated causing dizziness/giddiness, loss of
surface-dry (SSD), graded low absorption, high consciousness, contact with eyes etc, seek
density aggregates. Please consult your local immediate medical advice. The requirements may
Master Builders Solutions representative for advice vary depending on the application areas. Please
ensure to have proper ventilation while working in
confined areas. Contact Master Builders Solutions
Protective coatings
representative in case you need further details or
Subsequent coatings of MasterProtect anti- refer to the material safety datasheet of the product
carbonation barriers or silane impregnations should to know more.
be applied as recommend on the individual
datasheets.

TDS Ref No: MasterEmaco S 466/04/11/2022

® = registered trademark of a MBCC Group member in many countries of the world

The technical information and application advice given in this Master Builders Solutions publication are based on the
STATEMENT OF present state of our best scientific and practical knowledge. As the information herein is of a general nature, no
RESPONSIBILITY assumption can be made as to a product's suitability for a particular use or application and no warranty as to its
(Disclaimer) accuracy, reliability or completeness either expressed or implied is given other than those required by law. The user is
responsible for checking the suitability of products for their intended use.

Field service where provided does not constitute supervisory responsibility. Suggestions made by Master Builders
NOTE Solutions either orally or in writing may be followed, modified or rejected by the owner, engineer or contractor since
they, and not Master Builders Solutions, are responsible for carrying out procedures appropriate to a specific
application.

Master Builders Solutions India Private Limited


Registered office: Plot No D-126,
TTC Industrial Area, MIDC,
Shiravane, Navi Mumbai - 400706,
Maharashtra, India
Tel: +91 8657906776
E-mail: Construction-india@mbcc-group.com
www.master-builders-solutions.com/en-in
MasterInject® 1315
Low viscosity epoxy resin with long potlife for crack injection

DESCRIPTION Colour Clear Amber Pale


Yellow
MasterInject 1315 is a low viscosity epoxy resin
based crack injection resin system long mixed Mix Ratio 77:23 pbw
potlife designed for sealing cracks in concrete and Density (Mixed) 1.05kg/L
restoring its structural integrity.
Application Temperature 15°C - 35°C
RECOMMENDED USES
 Stabilised cracks in structural members APPLICATION
 Sealing of cracks from 0.1mm to 10mm Surface preparation
 Unfilled voids behind tiles or stone facades
Remove all grease, oil, dust, residual curing
 Bonding of steel plates to concrete
compound, mould release agent or other
 Rapid structural repair of concrete
contaminant that could impair adhesion of the
 Grouting dowels injection ports. The injection ports should be applied
FEATURES AND BENEFITS over 6-10mm diameter holes drilled at least 50-
 Solvent free -Low VOC and non-shrink 75mm into the concrete element. For deeper
 Pre-proportioned packaging - No job site penetration deeper holes should be considered.
errors Use MasterBrace ADH 2200 to adhere the
 Low viscosity - Easy to inject into fine cracks injection ports over the holes ensuring that the
 High bond strength to concrete -Can restore adhesive does not block the drilled holes. Allow the
the structural integrity of the concrete MasterBrace ADH 2200 to cure before injecting .
 Cures hard at low temperatures -Wide The ports should follow the crack at intervals of
application range 500mm or a maximum of 1m centres. Inject from the
lowest point or furthest point towards the centre
 High heat deflection temperature – Suitable checking for resin coming out of the next hole along.
for high ambient temperature environments For detailed instructions on crack injection ask you
 Can be applied for Wet and Damp Substrates Master Builders Solutions representative for the
“MasterInject guide to crack injection”.
PROPERTIES Mixing
Proportion part kits accurately mixing only what can
Mixed resin and hardener only
be used in less than 30 minutes. Thoroughly stir
Viscosity (25°C) <500 cps Part A, add Part B and blend thoroughly using a
Compressive Strength 65 MPa @ 1 day slow speed mixer fitted with a suitable paddle.
(ASTM C579) CURING
70 MPa @ 7 days
Flexural strength (ASTM C 45 MPa @ 1 day Cure time will vary depending on the ambient
6319 part 3) temperature, quantity mixed and placed.
55 MPa @ 7 Days MasterInject 1315 will have fully cured after 7 days
Tensile 18 MPa at 23°C.
strength(ASTMD638)
ESTIMATING DATA
7days
Pot life 50 minutes @ 25°C Usage will depend on the injection pressure and the
size of the cracks and is impossible to estimate.
30 minutes @ 40°C
PACKAGING
Slant shear bond strength >18 MPa (Concrete
(ASTM C 882 @ 7 days) failure) MasterInject 1315 comes in 1.08 kg and 4.32 kg
pack sizes.
Bond strength >2.5 MPa (concrete
failure)
Tack free time 6.5 hours @ 25°C SHELF LIFE
Meets the requirements of ASTM C881 Type 1 & 4 MasterInject 1315 can be stored in tightly closed
Grade 1 Class B & C original containers for 12 months at moderate
temperature.
Part A Part B Mixed
Supply Form Liquid Liquid Liquid

Page 1 of 2
MasterInject® 1315
PRECAUTIONS
Please refer the Material Safety Data Sheet for
handling and storage of this product.

MasterInject 1315/04/05/2022

® = registered trademark of a MBCC Group member in many countries of the world

The technical information and application advice given in this Master Builders Solutions publication are based on the
STATEMENT OF present state of our best scientific and practical knowledge. As the information herein is of a general nature, no
RESPONSIBILITY assumption can be made as to a product's suitability for a particular use or application and no warranty as to its
(Disclaimer) accuracy, reliability or completeness either expressed or implied is given other than those required by law. The user
is responsible for checking the suitability of products for their intended use.

Field service where provided does not constitute supervisory responsibility. Suggestions made by Master Builders
NOTE Solutions either orally or in writing may be followed, modified or rejected by the owner, engineer or contractor since
they, and not Master Builders Solutions, are responsible for carrying out procedures appropriate to a specific
application.

Master Builders Solutions India Private Limited


Registered office: Plot No D-126,
TTC Industrial Area, MIDC,
Shiravane, Navi Mumbai - 400706,
Maharashtra, India
Tel: +91 8657906776
E-mail: Construction-india@mbcc-group.com
www.master-builders-solutions.com/en-in
3
03 64 00 Injection Grouting
Maintenance of
31 01 70
Tunneling and Mining

31 31 73 00 Tunnel Grouting

MasterRoc® MP 355 1K
One component polyurethane injection foam to stop small to
medium water ingress

Description Features
MasterRoc MP 355 1K „ Gets activated in moist environment
product is a solvent „ Good bonding to wet surfaces
free, one component
polyurethane resin which „ Modification of the foaming action can be achieved using an accelerator
turns into a foam when
it comes in contact with Benefits
humidity or moisture. „ Rapid reaction and excellent bonding feature make it more effective to stop water
ingress
Applications „ Adjustable reaction time with the associated accelerator provides application flexibility
„ To stop small to medium
water ingress in Performance Characteristics
underground structures
Technical Data
„ Filling of voids
containing water MasterRoc MP 355 1K Resin

„ Crack injection of Density at 68 °F (20 °C): 72.4 lb/ft3 (1.16 g/cm3)


above or below grade Viscosity at 73 °F (23 °C): 320 mPa.s
structures, including
Color: Brown
water/wastewater tanks,
storm pipes, manholes, Application temperature: 40 °F to 105 °F (5 °C to 40 °C)
culvert joints, and dams Maximum foam expansion rate: (10% accelerator dosage) 25 – 30

MasterRoc MP 355 1K Accelerator


Density at 68 °F (20 °C) 61.2 lb/ft3 (0.98 g/cm3)
Viscosity at 73 °F (23 °C) 320 mPa.s
Color: Clear to yellowish

A brand of

page 1 of 3
MasterRoc MP 355 1K Technical Data Sheet

Guidelines for Use Storage and Handling


Dosage and Application Procedure: Add the MasterRoc MP 355 1K Storage Temperature and Shelf Life: MasterRoc MP 355 1K
Accelerator (up to 10% by volume of the resin, depending Resin and MasterRoc MP 355 1K Accelerator must be
on the required reaction time) to MasterRoc MP 355 1K stored in airtight containers in a cool, dry place within a
Resin. Mix thoroughly and quickly. Inject the mixture through temperature range of 40 ºF and 95 ºF (5 ºC and 35 ºC).
a single component injection pump. The moisture / water in If stored in original containers under the above mentioned
the ground will activate the foaming reaction. In the case of conditions, the MasterRoc MP 355 1K products have a shelf
dry ground, flush the space with water before injecting the life of 24 months. MasterRoc MP 355 1K products must be
product. protected from freezing.
Reaction Time: The reaction time depends on the temperature Safety: MasterRoc MP 355 1K Resin and MasterRoc
of the ground and that of the MasterRoc MP 355 1K resin, MP 355 1K Accelerator are non-hazardous. However,
as well as the accelerator dosage. Table 1 below shows the standard safety procedures when handling chemical
reaction time based on laboratory trials. Field trials should products should be followed (including wearing gloves and
be performed in advance to establish the required reaction safety glasses).
time. Avoid eye and skin contact. If skin contact occurs, wash with
Table 1: Reaction time with 10% moisture and 10% accelerator plenty of water and soap. In case of eye contact, rinse with
plenty of water and seek medical advice.
40 ºF 50 ºF 60 ºF 68 ºF
Initial Temperature* (5 ºC) (10 ºC) (15 ºC) (20 ºC) Uncured products should be prevented from entering local
Start of reaction (seconds) 120 60 25 10 drainage systems and water courses. Spillage must be
collected using absorbent materials, such as sawdust and
End of reaction (seconds) 300 200 110 50
sand, and disposed of in accordance with local regulations.
Foam expansion rate (approximate) 25 25 25 30
Packaging
*temperature of both the product and water during the test
MasterRoc MP 355 1K Resin is available in 6 gal (22 L) pails.
Cleaning of Injection Equipment: During short breaks or intervals MasterRoc MP 355 1K Accelerator is available in 0.7 gal
longer than an hour in the injection process, fill the pump and (2.5 L) bottles.
hoses with non-accelerated MasterRoc MP 355 1K Resin to
avoid blockages. Related Documents
After the injection process, pump an appropriate cleaning Safety Data Sheets: MasterRoc MP 355 1K Resin and
and maintenance agent (such as MasterRoc MP 230 CLN MasterRoc MP 355 1K Accelerator
product) or an oil containing no moisture, through the pump
and injection hoses until MasterRoc MP 355 1K Resin is Additional Information
completely flushed out. Store the pump and hoses with the For additional information on MasterRoc MP 355 1K Resin
cleaning agent inside and seal all the openings. and MasterRoc MP 355 1K Accelerator, contact your local
sales representative.
Master Builders Solutions, a brand of MBCC Group,
is a global leader of innovative chemistry systems and
formulations for construction, maintenance, repair and
restoration of structures. The Admixture Systems business
provides advanced products, solutions and expertise that
improve durability, water resistance, energy efficiency,
safety, sustainability and aesthetics of concrete structures,
above and below ground, helping customers to achieve
reduced operating costs, improved efficiency and enhanced
finished products.
Utilizing worldwide resources, the Master Builders Solutions
community of experts are passionate about providing
solutions to challenges within all stages of construction,
as well as the life cycle of a structure. At Master Builders
Solutions we create sustainable solutions for construction
around the globe.

www.master-builders-solutions.com/en-us page 2 of 3
MasterRoc MP 355 1K Technical Data Sheet

Limited Warranty Notice


Master Builders Solutions Admixtures US, LLC (“Master
Builders Solutions”) warrants this product to be free from
manufacturing defects and to meet the technical properties
on the current Technical Data Guide, if used as directed within
shelf life. Satisfactory results depend not only on quality
products but also upon many factors beyond our control.
MASTER BUILDERS SOLUTIONS MAKES NO OTHER
WARRANTY OR GUARANTEE, EXPRESS OR IMPLIED,
INCLUDING WARRANTIES OF MERCHANTABILITY
OR FITNESS FOR A PARTICULAR PURPOSE WITH
RESPECT TO ITS PRODUCTS. The sole and exclusive
remedy of Purchaser for any claim concerning this product,
including but not limited to, claims alleging breach of
warranty, negligence, strict liability or otherwise, is shipment
to purchaser of product equal to the amount of product that
fails to meet this warranty or refund of the original purchase
price of product that fails to meet this warranty, at the sole
option of Master Builders Solutions. Any claims concerning
this product must be received in writing within one (1) year
from the date of shipment and any claims not presented within
that period are waived by Purchaser. MASTER BUILDERS
SOLUTIONS WILL NOT BE RESPONSIBLE FOR ANY
SPECIAL, INCIDENTAL, CONSEQUENTIAL (INCLUDING
LOST PROFITS) OR PUNITIVE DAMAGES OF ANY KIND.
Purchaser must determine the suitability of the products
for the intended use and assumes all risks and liabilities in
connection therewith. This information and all further technical
advice are based on Master Builders Solutions' present
knowledge and experience. However, Master Builders
Solutions assumes no liability for providing such information
and advice including the extent to which such information
and advice may relate to existing third party intellectual
property rights, especially patent rights, nor shall any legal
relationship be created by or arise from the provision of such
information and advice. Master Builders Solutions reserves
the right to make any changes according to technological
progress or further developments. The Purchaser of the
Product(s) must test the product(s) for suitability for the
intended application and purpose before proceeding with a
full application of the product(s). Performance of the product
described herein should be verified by testing and carried
out by qualified experts.

© MBCC Group  04/22  DAT-1198


® registered trademark of a MBCC Group member in many countries of the world www.master-builders-solutions.com/en-us
Master Builders Solutions Admixtures US, LLC Master Builders Solutions Canada, Inc.
23700 Chagrin Boulevard 1800 Clark Boulevard
Cleveland, Ohio 44122-5544 Brampton, Ontario L6T 4M7
USA  800-628-9990 CANADA  289-360-1300 page 3 of 3

You might also like