Professional Documents
Culture Documents
MS 2200
MS 2200
SERVICE MANUAL
Description: 1. : Weight unit 2. 3. 4. 5. 6. : The time for auto off : Capacity : Calibration weight : Division : Gravity compensation
Start to calibrate.
END
CALIBRATION PROCEDURE
START
Press Unit key to select weight unit (kg Press Zero key without releasing, and press Unit key 3 times. or lb) to calibrate.
Load calibration weight. Display shows the gravity value of the factory 9.789. Press Hold key to Display shows span count. Please see Note 1 for span count range. move to the desired digit, and press Unit key to set the gravity of destination.
Press Tare key to confirm the entered gravity. Display show zero count XXXX. Please see Note 1 for the zero count range.
Display shows
0 End
Note 1: Capacity Calibration Capacity Calibration weight Span Count (kg) Span Count (lb) Span Control RX Zero Count Full 200 kg / 500 lb 8000 ~ 20000 9100 ~ 22650 110 K 5000 ~ 6000 250 kg / 500 lb 1/2 load 100 kg / 200 lb 4000 ~ 10000 3630 ~ 9070 1/4 load 50 kg / 100 lb 2000 ~ 5000 1815 ~ 4540
2. If the zero count value is out of range, please adjust the R1, R2 of the main board (CH-0525) to obtain correct zero count. 3. If the span count value is out of range, please adjust the RX of the main board (CH-0525) to obtain correct span count.
GRAVITY COMPENSATION:
1. When the operator enables from the function setting procedure describe on page
3, the scale allows the operator to change the setting of gravity value as follows: (1) Press and hold UNIT key 3 seconds to enter gravity compensation mode, the display will show 9.789 (the gravity value of Taiwan factory). (2) Enter the desired gravity value. (Press TARE key to move to the desired digit, and press UNIT key to set the gravity of destination. At last, press TARE key to confirm the entered gravity.) (3) The scale will do gravity compensation automatically. 2. If the operator disables from the function setting procedure described on page 3,
the scale will not allow the operator to re-calibrate the scale by simply changing the setting of gravity value.