Professional Documents
Culture Documents
Diala BX
Diala BX
Applications
Specification and Approvals
• Industrial transformers
Electrical insulating oil for transformers and Shell Diala BX meets the following specifications:
switch-gears. IEC 296 (1982) Class I A
Grid and Industrial transformers up to maximum
load. IEC 60296 (2003)
Table 2 Transformer Oil(Inhibited)
• Electrical equipment
Components like rectifiers, circuit breakers,
switch-gears.
Storage precautions
Advice on applications not covered in this leaflet may The critical electrical properties of Shell Diala BX
be obtained from your Shell Representative. are easily compromised by trace contamination
with foreign material. Typically encountered
contaminants include moisture, particles, fibers
Performance Features and Advantages and surfactants. Therefore, it is imperative that
electrical insulating oils be kept clean and dry.
• Good oxidation stability It is strongly recommended that storage
Diala BX offers inherent natural resistance to oil containers be dedicated for electrical service and
degradation. include air-tight seals. It is further recommended
that electrical insulating oils be stored indoors in
• Good dielectric strength climate-controlled environments.
It exceeds the requirements from all major
specifications.
Health and Safety
• Very good low temperature properties Guidance on Health and Safety are available on
The naphthenic nature of the feedstock of Diala the appropriate Material Safety Data Sheet which
BX provides a good low temperature performance can be obtained from your Shell representative.
without adding any additives.
Shell Diala BX is free of polychlorinated biphenyls
• Good heat transfer characteristics (PCB).
The good low temperature properties of the oil
ensures proper heat transfer inside the
Protect the environment
transformer even from lowest starting
Take used oil to an authorized collection point. Do
temperatures.
not discharge into drains, soil or water.
Neutralisation value mg KOH/g IEC 296 / IEC < 0.03 0.01 max < 0.03
62021
Breakdown voltage kV IEC 156 / IEC Min 30 (bulk) Min 30 before >30
60156 treatment
Min 50 (drum) ( >70 upon
Min 70 after treatment)
treatment
<30 bulk
Dielectric dissipation factor at DIN 57370 / 0.005 max 0.005 max 0.001
90ºC (after treatment) IEC 247
These characteristics are typical of current production. Whilst future production will conform
to Shell's specification, variations in these characteristics may occur.